| LOST JEEPS http://www.lostjeeps.com/forum/phpBB3/ |
|
| Good Fluid Capacity Chart and torque values list http://www.lostjeeps.com/forum/phpBB3/viewtopic.php?f=16&t=9916 |
Page 1 of 1 |
| Author: | AdamIsAdam [ Thu Jun 29, 2006 12:27 pm ] |
| Post subject: | Good Fluid Capacity Chart and torque values list |
I stumbled upon this at the Amsoil web site. I found it helpful and more detailed than info I've seen in the past so I wanted to poste it here. There is a different charge for the 4-cyl engines. site is here 2003 JEEP LIBERTY 3.7L 6-cyl VIN Code K BOSCH SPARK PLUGS All submodels Plug......B4428[1] Wire......NR 1. Do Not Gap. Gap is not adjustable. BOSCH WIPER BLADES Driver side......B40919 Passenger side......B40919 FILTERS Oil Filter......EaO34/SDF34 Air Filter......42329 Trans......58843[1] Trans......58846[2] 1. 4WD - Spin - on + pan filter together in one kit 2. 2WD - Spin - on + pan filter together in one kit LUBRICANTS & FLUIDS Engine Oil Grade 1......API* Series 2000 Synthetic 0W-30 Motor Oil SAE 5W-30 Synthetic Motor Oil SAE 10W-30 Synthetic Motor Oil SAE 5W-30 XL Synthetic Motor Oil Above 0°F......10W-30 Below 100°F......5W-30[1] Manual Transmission,.....GLS[2] AMSOIL Synthetic Synchromesh Transmission Fluid Automatic Transmission.....AP4 Synthetic Automatic Transmission Fluid Differential, Front .....GL-5[3] 75W-140 Severe Gear 75W-140 SAE 80W-140 Synthetic Gear Lube Standard Differential, Rear 8 1/4.....GL-5[4] 75W-90 Severe Gear 75W-90 SAE 75W-90 Synthetic Gear Lube Controlled Slip Differential, Rear 8 1/4.....GL-5*[5][6] 75W-90 Severe Gear 75W-90 Standard Differential, Rear W/ Towing package.....GL-5[7] 75W-140 Severe Gear 75W-140 SAE 80W-140 Synthetic Gear Lube Transfer Case,.....AP4 Synthetic Automatic Transmission Fluid Fluids Power Steering Fluid.....PS Brake Fluid.....HB Clutch Fluid.....HB 1. Except TURBO & 1991 3.3L engine. Preferred 2. GLS is a special gear lube, Mopar part no. 04874464. 3. Synthetic based oil. 4. All W/ Trailer Tow PKG use synthetic GL-5 oil SAE 75W-140. Mopar part no. 04874469. 5. CS IDENTIFICATION: Metal tag atached to rear cover stamped W/ "Use Limited-Slip DIFF Lube only". 6. All W/ Trailer Tow PKG use synthetic GL-5 oil SAE 75W-140. Mopar part no. 04874469. 7. Synthetic based oil. CAPACITIES Engine, with filter..........5.0 quarts Cooling System, Initial Fill..........14.0 quarts Automatic Transmission, 45RFE Initial Fill..........5.0 quarts[1][2] Automatic Transmission, Total Fill 4 speed 45RFE..........14.0 quarts 4 speed 42RLE..........8.8 quarts Manual Transmission, NV1500..........4.9 pints Manual Transmission, NV3550..........4.9 pints Differential, Front..........2.5 pints[3] Differential, with 198 RBI Rear..........3.6 pints Differential, with 8.25 RBI Rear..........4.2 pints Transfer Case,NV231..........3.0 pints Transfer Case,NV242..........3.4 pints 1. With ENG at operating temperature, shift through all gears. Check fluid level in NEUTRAL and add fluid as needed. 2. DTC'S may be set , reset W/ DRB III, if necessary 3. Fill no higher than 1/2" below fill plug opening. TORQUES Oil Drain Plug.....25 ft-lbs Transfer case Fill Plug.....15-25 ft-lbs Drain Plug.....15-25 ft-lbs Manual Transmission NV1500 5-SPD Fill Plug.....25 ft-lbs Drain Plug.....25 ft-lbs Manual Transmission NV3550 5-SPD Fill Plug.....14-20 ft-lbs Drain Plug.....14-20 ft-lbs SERVICE INTERVAL AMSOIL Product Recommendation and Drain Interval Guide (g1490) |
|
| Page 1 of 1 | All times are UTC - 5 hours [ DST ] |
| Powered by phpBB © 2000, 2002, 2005, 2007 phpBB Group http://www.phpbb.com/ |
|