LOST JEEPS
http://www.lostjeeps.com/forum/phpBB3/

Problem with 4WD (UPDATE!)
http://www.lostjeeps.com/forum/phpBB3/viewtopic.php?f=3&t=2565		 Page 1 of 1
Author:  nails023 [ Sat Oct 08, 2005 8:22 am ]
Post subject:  Problem with 4WD (UPDATE!)
I just installed a Frankenlift last weekend. Everything was working great. Today we had a little ice on the roads here and I shifted into 4HI (25 mph in a straight line) and I heard clicking coming from underneath somewhere up front. I kept going straight for about 50 yards to see if it would go away. It didn't. I even went into 4LO and heard the same thing. Does anyone have any idea what this could be? I am still runnning the stock tires and rims until I get an alignment. As soon as I go back to 2HI the clicking goes away. Any suggestions as to what it coud be? :? I forgot to mention I have the Command-Trac Part time 4WD system.
Author:  MattyMac1 [ Sat Oct 08, 2005 12:16 pm ]
Post subject: 
Rock or stone in your tire?? :idea:
Author:  nails023 [ Sat Oct 08, 2005 2:22 pm ]
Post subject: 
I did a little more investigating. It definately seems to be associated with my front driveshaft. It doesn't click when I coast in 4HI but when I press on the accelerator it clicks. It speeds up as I speed up.
Author:  nails023 [ Mon Oct 10, 2005 9:51 am ]
Post subject: 
Any suggestions? :?:
Author:  Edwin [ Mon Oct 10, 2005 11:47 am ]
Post subject: 
Look at the front drive shaft and see if there is any weeds or limbs wrapped up on it.
Author:  Skyjump136 [ Mon Oct 10, 2005 11:57 am ]
Post subject: 
Sounds like a bad CV. That's what I had with the Skyjacker kit. I think some CVs are not built to tolerances and for an unfortunate few a lift really accentuates the problem. Replaced mine when I installed the Frankenlift and have never had the problem again.

Find a steep hill where you can engage 4 wheel drive. Does the noise get louder going up and softer going down? If so, I can almost bet it is your CV. Try it out.
Author:  nails023 [ Tue Oct 11, 2005 8:37 am ]
Post subject: 
If it is a bad CV. Would this be a warranty issue? Or because I lifted it would I be out of pocket for this? Skyjump what was your situation?

Thanks
Author:  Skyjump136 [ Tue Oct 11, 2005 9:17 am ]
Post subject: 
I never took it to the dealer because I assumed they would not warranty it (even though I knew the CV must have been bad before the lift). I got a CV off of www.car-part.com. It cost me $150 for a joint with 5,000 miles on it. It came with a 90 warranty and I installed it myself. So overall it was not a huge expense or hassle.

Edit: If you do go through the dealer expect them to quote you over a grand for the CV (parts only)! Crazy.
Author:  nails023 [ Tue Oct 11, 2005 9:25 am ]
Post subject: 
How much of a pain was it to install?

I have an appointment here in Iceland at the Mercedes Dealer (No Jeep dealerships) to see if they are going to cover it under warranty and to make sure that is the problem. If they don't cover it I will go that route as well.
Author:  Skyjump136 [ Tue Oct 11, 2005 9:30 am ]
Post subject: 
It only took two hours. As long as you have the tools it isn't difficult. I'm lucky enough to have a friend who's a mechanic.

If you did your lift then this requires a lot of the same work.
Author:  nails023 [ Tue Oct 11, 2005 9:38 am ]
Post subject: 
Yeah we did the lift. I am on a military base and have access to an auto hobby shop with almost anything you need. I will give them a call and see if they have a knowledgeable person just in case they come back and say no on the warranty thing. Again this is all as long as they don't think it is something else.
Author:  nails023 [ Mon Oct 24, 2005 8:38 am ]
Post subject: 
I just got back from the dealer. (Mercedes Service Dept here in Iceland.)
They just ordered me a new Trasnfer Case. :? They said that was my problem. They did not say a word about my lift and everything is covered under warrenty. :D
Author:  USAFCOP [ Mon Oct 24, 2005 12:56 pm ]
Post subject: 
Good for you!!!!

That is awesome.

Just do not tell them it is lifted... Afterall they are Mercedes techs not Jeep techs :roll:
Page 1 of 1 All times are UTC - 5 hours [ DST ]
Powered by phpBB © 2000, 2002, 2005, 2007 phpBB Group
http://www.phpbb.com/