LOST JEEPS http://www.lostjeeps.com/forum/phpBB3/ |
|
KJ Safari Snorkel SS1130HF http://www.lostjeeps.com/forum/phpBB3/viewtopic.php?f=3&t=54326 |
Page 1 of 1 |
Author: | FlyingWil [ Sat Jul 17, 2010 12:21 pm ] |
Post subject: | KJ Safari Snorkel SS1130HF |
Started on the Safari Snorkel install on the KJ last night. So far everything fit the US KJ's, with the exception of the Radio Antenna. Full write-up to follow. |
Author: | John Galt [ Sat Jul 17, 2010 12:54 pm ] |
Post subject: | Re: KJ Safari Snorkel SS1130HF |
Looks sweet man. I will ship out the stock air box as soon as the K&N shows. |
Author: | FlyingWil [ Sat Jul 17, 2010 3:44 pm ] |
Post subject: | Re: KJ Safari Snorkel SS1130HF |
Safari Snorkel SS1130HF install write up Well, the long awaited SS1130HF finally showed up at our shop. Designed for the Jeep KJ Cherokee with the 3.7L Down Under. I was a bit unsure of the fitment due to differences in the OZ spec and US spec KJ's. What better way to test it out than to drill some huge holes in my wife's Jeep!? Note: If you are planning on installing a SS1130HF on your KJ, please note that at this time the Radio Antenna will need to modified, and you will be removing the entire front passenger fender, sliders and certain front bumpers may need to be removed to remove the front fender. Installation Time: aprox 6 hours. Step 1: Remove the fender flare. You'll need extra retaining clips to replace ones that may have broken during removal. Step 2: Remove the air cleaner assembly, and the inlet duct can be thrown out per the directions. Step 3: Align the outer fender templates and mark the holes. Step 4: Drill holes marked, de burr and use touch up paint to prevent rust. Step 5: Remove fender panel. Step 6: Align inner fender template and mark. Step 7: Drill holes marked, de burr and use touch up paint to prevent rust. Step 8: Align engine bay template and mark. Step 9: Drill holes marked, de burr and use touch up paint to prevent rust. Step 10: Reinstall fender panel. We marked the washers and re aligned to the marks. Step 11: Install snorkel body. Apply loctite to the studs, and and install upper mounting plate. Note: This is the difference in the US Spec and OZ Spec KJ's. The antenna location is in the way of the snorkel. The antenna can either be relocated or bent, we bent ours, and secured with a zip tie. Step 12: Remove A-pilar molding and trim according to the instructions. Drill, de burr, and install pop rivets. Step 13: Measure 3.3" up and .35" in from the third rib and mark... Drill with 92mm hole saw, and remove all the ribs from the air intake. Install air intake connector with silicone and pop rivet through holes. Step 14: Plug OEM intake with plate provided, and silicone drain holes on bottom of factory air box. Step 15: Install air box and connect the intake connector with hose clamp. Step 15: See note in step 11. Step 16: Re-install fender flares, and enjoy. |
Author: | JustinP [ Sat Jul 17, 2010 4:43 pm ] |
Post subject: | Re: KJ Safari Snorkel SS1130HF |
Very nice. I love it. |
Author: | bmrrwolfe [ Sat Jul 17, 2010 5:35 pm ] |
Post subject: | Re: KJ Safari Snorkel SS1130HF |
I want one! |
Author: | digglesworth [ Sun Jul 18, 2010 12:18 am ] |
Post subject: | Re: KJ Safari Snorkel SS1130HF |
"weeeee allllllllll live in a yellllllllooooooooow submarine".................. well a silver submarine in your case that really does look good.... dang good...... |
Author: | MtnLuvr [ Sun Jul 18, 2010 9:30 am ] |
Post subject: | Re: KJ Safari Snorkel SS1130HF |
Nice job and nice write-up. |
Author: | 2006 KJ [ Sun Jul 18, 2010 10:46 pm ] |
Post subject: | Re: KJ Safari Snorkel SS1130HF |
looks great! do you have any more pictures of your hood? |
Author: | FlyingWil [ Mon Jul 19, 2010 9:48 am ] |
Post subject: | Re: KJ Safari Snorkel SS1130HF |
2006 KJ wrote: looks great! do you have any more pictures of your hood? Let me check when I get work, I think I have some driveway shots of her jeep just after she got them on. I can't figure out how to link the pisc from my phone apparently my smart phone is smarter than me. |
Author: | tommudd [ Mon Jul 19, 2010 10:49 am ] |
Post subject: | Re: KJ Safari Snorkel SS1130HF |
Looks good Wil Been following on Expedition Portal as well. Too bad they took so long to come out. I had about 30 people interested in them last year when they said they would be released |
Author: | FlyingWil [ Mon Jul 19, 2010 11:42 am ] |
Post subject: | Re: KJ Safari Snorkel SS1130HF |
2006 KJ wrote: looks great! do you have any more pictures of your hood? Here you go: |
Author: | FlyingWil [ Mon Jul 19, 2010 11:43 am ] |
Post subject: | Re: KJ Safari Snorkel SS1130HF |
tommudd wrote: Looks good Wil Been following on Expedition Portal as well. Too bad they took so long to come out. I had about 30 people interested in them last year when they said they would be released Sierra Expeditions will gladly do a group buy if there is interest. Just let me know. |
Author: | FlyingWil [ Mon Jul 19, 2010 1:00 pm ] |
Post subject: | Re: KJ Safari Snorkel SS1130HF |
Thanks for all the kind words about the snorkel, and based upon the feed back we have received I can not stress enough, that the front fender (not the flare) has to be removed for installation of this Safari Snorkel. If you have sliders, or an aftermarket bumper, you will be removing the entire fender for this install. We had to remove the sliders to get to the two lower bolts just behind the bottom of the fender flare, and the two under the ARB bumper had to come out too. We were able to get it installed in about 5 to six hours, but we have installed a lot of snorkels. The instructions from Safari Snorkel calls for an 8 hour install time. |
Author: | dac44444 [ Thu Jul 22, 2010 12:26 pm ] |
Post subject: | Re: KJ Safari Snorkel SS1130HF |
I would be interested in the group buy? Please let me know? |
Author: | CRD Joe [ Thu Jul 22, 2010 10:14 pm ] |
Post subject: | Re: KJ Safari Snorkel SS1130HF |
Looks great. Nice job with the write up. |
Author: | Balance156 [ Tue Feb 03, 2015 7:42 pm ] |
Post subject: | Re: KJ Safari Snorkel SS1130HF |
Is there a review on this snorkel? |
Author: | Jeeparano63 [ Fri Nov 13, 2015 9:49 am ] |
Post subject: | Re: KJ Safari Snorkel SS1130HF |
Hi there, looking for a snorkel for my 2006 Jeep liberty Limited at a reasonable price I found a couple that were in the mid to hire range from 375 up I'm looking to see if there might be another one that was in the $200 range? My jeep is similar to yours, yours looks a lot better because you have that snorkel on it exclamation LOL, if you know of any different places that might be able to hook me up I'd be grateful thanks so much Chris you can email me at Chefn63@ aol.com As a liberty owner and lover you know where I'm standing right now this is been on me for a few months now to find one for a less ridiculous cost |
Author: | JeepMorrison [ Fri Nov 13, 2015 11:49 am ] |
Post subject: | Re: KJ Safari Snorkel SS1130HF |
Jeeparano63 wrote: Hi there, looking for a snorkel for my 2006 Jeep liberty Limited at a reasonable price I found a couple that were in the mid to hire range from 375 up I'm looking to see if there might be another one that was in the $200 range? My jeep is similar to yours, yours looks a lot better because you have that snorkel on it exclamation LOL, if you know of any different places that might be able to hook me up I'd be grateful thanks so much Chris you can email me at Chefn63@ aol.com As a liberty owner and lover you know where I'm standing right now this is been on me for a few months now to find one for a less ridiculous cost None in that price range. Sorry Sent from my SM-N900P using Tapatalk |
Author: | Jeeparano63 [ Fri Nov 13, 2015 11:59 am ] |
Post subject: | Re: KJ Safari Snorkel SS1130HF |
So where did you get your snorkel? |
Author: | jinyoo0501 [ Wed Dec 22, 2021 1:30 pm ] |
Post subject: | Re: KJ Safari Snorkel SS1130HF |
Hi, I have a 05 Liberty Renegade and looking to install this SS1130HF. it appears though on the website from a Canadian supply store says below. THIS PRODUCT FITS THE FOLLOWING: 2005 Jeep Liberty (KJ) Sport 2004 Jeep Liberty (KJ) Sport 2004 Jeep Liberty (KJ) Renegade 2004 Jeep Liberty (KJ) Limited 2003 Jeep Liberty (KJ) Renegade 2003 Jeep Liberty (KJ) Limited 2003 Jeep Liberty (KJ) Sport 2002 Jeep Liberty (KJ) Renegade 2002 Jeep Liberty (KJ) Limited 2002 Jeep Liberty (KJ) Sport Does this mean my 05 liberty renegade will not fit??? Thanks, |
Page 1 of 1 | All times are UTC - 5 hours [ DST ] |
Powered by phpBB © 2000, 2002, 2005, 2007 phpBB Group http://www.phpbb.com/ |