I just stick the tip of the bottle in the hole, turn the bottle on it's side slightly inverted, and squeeze the living s**t out of it. I've never had any trouble, spills, or sore hands afterwards. Maybe I'm just a brute?

_________________
--Greg
2005 CRD Sport in white
2.5" Daystar Lift Kit
245/75/16 Maxxis Buckshot Mudders

So how much goes in each diff again? 2 qts each?

_________________
2016 JKU RUBICON

other mods coming soon...

0311-DOC
I tried to look this up in the owner's manual at the time I did mine
but could only find specs, not capacities.
I bought 4 Quarts. The front takes a little less than the rear. I ended up
with abut 8 ounces left over. The book says to fill to 1/2" under the fill
hole, as if you could watch it. I just ''fill til spill'' then it's enough.
Good luck.

_________________
'06 Limited CRD, EHM, Unplugged MAF
Other Diesels: '77 MB 300, '84 VW Caddy, '99 Powerstroke
Diesels sold: '06 CRD, '02 &'03 Powerstroke, '03 & '05 DMax, '01 Jetta
Jeeps sold: '02 Liberty gasser, '06 Liberty CRD

from the FSM
Front Axle: 186 FIA(model 30) 1.24L or 2.6 pts.
Rear Axle : 8 1/4 2.08 or 4.4 pts.

Hey 1TDI4Me, did you say you found the 1/2 inch spec in the owners manual? I couldn't remember where I found that.

_________________
2006 CRD Sport Khaki

Lift Pump, Fuel Cooler
Raycor: head, filter, heater
Provent, ORM
SunCoast, TransGo, 2007 pump, B&M stacked plate tranny cooler
V6 Airbox, Wix Filter
AirLift 1000 Rear Air Bags
Fia front cover

Coming soon:
Fuel cooler bypass valve
InMotion tuning
new muffler
300,000 miles here I come

I used one of these when I did my transfer case. It really made the job easy.

_________________
2006 Liberty Limited CRD Bright Silver Metallic (NOW SOLD)
All Recalls Performed
100k extended warranty
Fumoto Oil Drain Valves (Oil Pan & Transfer Case)
V6 Airbox Mod
New Driveshaft, New EGR
2003 Wrangler Sport 4.0L, Bright Blue
2007 Wrangler Sahara Unlimited 4 Door, Red Rock Crystal Pearl WOW!!!

So, how does one know if they have "Trac-lok" or not? I have a 2005 Limited CRD without the off-road package. The rest of the gear oil change seems straightforward. I'm glad you folks all reminded me about it.

_________________

2005 Silver CRD Limited
245/75R16 GoodYear Duratracs
Fumoto drain | ProVent CCV Filter
Stanadyne FM100 filter | Cummins fuel pump
GDE Eco | SEGR | BoulderBars | FrankenLift | Frankenskids

You should really get a build sheet And if you bought it new and have the window sticker it will be listed there also It has all that info on it. Also I think I've seen mention of a tag, lable or something attatched on the rear diff

_________________
Atlantic Blue 06 CRD Limited (his)
Joined by a 2000 XJ Classic (hers)

I use Royal Purple 75w-90 and the 140 . the 140 for the back and the 75 for the front. I went to Advance Auto Parts and bought a gasket for the rear Differential cover. I didn't torket as the book said, I just torket by touch and no leaks CRD seems smoother than before.

You can also jack up the rear end so the tire comes off the ground, then turn one, and if the other tire rotates the opposite direction the you do not have Trac-lok