LOST JEEPS
http://www.lostjeeps.com/forum/phpBB3/

2005 CRD Grill Replacement Problem
http://www.lostjeeps.com/forum/phpBB3/viewtopic.php?f=5&t=37532		 Page 1 of 1
Author:  DOC4444 [ Thu Nov 20, 2008 11:40 am ]
Post subject:  2005 CRD Grill Replacement Problem
I bought a new grill to mount a FIA blanket on. It arrived with both the lower outboad mounting tabs broken off.

1. Are these really needed?

2. It's cold here and I don't want to break any of the tabs on the existing grill when I remove it.

Looks like the top tabs should come off first, but then the bottom looks like you may have to insert a tool, etc...

Anyone done this successfully? (I'll try to get it as warm as possible.)

Thanks,

DOC
Author:  blake1827 [ Thu Nov 20, 2008 5:25 pm ]
Post subject: 
while I'd be careful switching out the grill in colder weather since the plastic is much more brittle and prone to snap. Wait til above 50 F I'd suggest or leave it sit in the sun a while. removing the grill is easy, I've done it a couple times now, and just last weekend to sandwich a tarp for a makeshift winter front.

All you need is a big flat head screwdriver. Work from one side to the other pop off the tab on the headlight, then press the next tab towards the motor and slide the screwdriver horizontal along the edge to help pop off the tab. There's a small lip and it will pop off once clear. The last 1 or 2 tend be be a bit tighter since the grill will be slightly twisted but just go easy and once all the tabs are off just pull the top down towards you like a tailgate and it will come right out!
Author:  hatchetman [ Fri Nov 21, 2008 12:53 pm ]
Post subject: 
Take the grill in the house to warm it up. Let it set for several hours, roll out the blanket and let it lay flat. Install the snaps using the blanket as the template. When you put the grill back on the jeep the blanket will be nice and snug and look good.
Page 1 of 1 All times are UTC - 5 hours [ DST ]
Powered by phpBB © 2000, 2002, 2005, 2007 phpBB Group
http://www.phpbb.com/