It is currently Mon Mar 18, 2024 10:28 pm

All times are UTC - 5 hours [ DST ]




Post new topic Reply to topic  [ 10 posts ] 
Author Message
 Post subject: P1202 sudden
PostPosted: Tue Mar 08, 2022 11:39 pm 
Offline
LOST Newbie

Joined: Wed Feb 20, 2019 2:58 am
Posts: 90
I am getting a P1202 and limp mode out of no where. OBDFusion says fuel pressure is fine, ~6k idle and 12k+ under load. I can clear the code and its fine and then comes back withing a minute or so, sometimes a little longer. I did check fuel injector #2 wiring at the injector and there was a small break in the wire sheath in a few spots, cut out the bad spots and replace with no change. Un plugged and re plugged all four injector connectors, and the fuel rail sensor. Could not reach the fuel quality sensor so have not checked it yet but looked to be seated. Have not done in major work in almost a year so nothing has been touched. Any ideas where to start?

_________________
06' Silver Limited CRD

Secondary fuel filter from wwdiesel
Northstar AGM
GDE Hot Tune
EGR delete
Suncoast TC
Transgo Kit
Carter Intank-pump
SAMCO Hoses
Silicone Intake hose
Silicone Vacuum hoses
Hayden HD Fan Clutch
ARB Front Bumper
Bosch 5V glow plugs
Gen II Fuel Head
Rockfather II Lift
GM 11 Blade fan


Top
 Profile  
 
 Post subject: Re: P1202 sudden
PostPosted: Wed Mar 09, 2022 3:26 am 
Offline
Moderator
Moderator
User avatar

Joined: Sat Aug 24, 2013 11:36 pm
Posts: 7155
Location: Central GA
timothyd wrote:
I am getting a P1202 and limp mode out of no where. OBDFusion says fuel pressure is fine, ~6k idle and 12k+ under load. I can clear the code and its fine and then comes back withing a minute or so, sometimes a little longer. I did check fuel injector #2 wiring at the injector and there was a small break in the wire sheath in a few spots, cut out the bad spots and replace with no change. Un plugged and re plugged all four injector connectors, and the fuel rail sensor. Could not reach the fuel quality sensor so have not checked it yet but looked to be seated. Have not done in major work in almost a year so nothing has been touched. Any ideas where to start?

Have you checked the Fuel Pressure Solenoid (Fuel Rail Pressure Control Valve) located on the end of the fuel rail? Wires, connections, etc...

_________________
Supporting Vendor and Moderator of LOST
05 Jeep Liberty CRD Limited :JEEPIN:
Ironman Springs/Bilstein/Shocks
Yeti StgIV Hot Tune
Week's BatteryTray
No FCV/EGR
Samcos/ProVent
SunCoast/Transgo
Carter Intank-pmp
2mic.Sec.Fuel Filter
Flowmaster/NO CAT
V6Airbox/noVH
GM11 Bld.fan/HDClutch
IronrockArms/wwdieselMount

98 Dodge Cummins 24 Valve


Top
 Profile  
 
 Post subject: Re: P1202 sudden
PostPosted: Wed Mar 09, 2022 8:34 pm 
Offline
LOST Newbie

Joined: Wed Feb 20, 2019 2:58 am
Posts: 90
Sure did, ran cleaner through it today and let it idle for 20 minutes with no error. Revved up to 2500 and then the light comes on.

_________________
06' Silver Limited CRD

Secondary fuel filter from wwdiesel
Northstar AGM
GDE Hot Tune
EGR delete
Suncoast TC
Transgo Kit
Carter Intank-pump
SAMCO Hoses
Silicone Intake hose
Silicone Vacuum hoses
Hayden HD Fan Clutch
ARB Front Bumper
Bosch 5V glow plugs
Gen II Fuel Head
Rockfather II Lift
GM 11 Blade fan


Top
 Profile  
 
 Post subject: Re: P1202 sudden
PostPosted: Sun Mar 20, 2022 9:55 pm 
Offline
LOST Newbie

Joined: Wed Feb 20, 2019 2:58 am
Posts: 90
I am down to either of these, what seems more likely to try first?


HPFP Fuel Pressure Regulator

Fuel Rail Pressure Solenoid

_________________
06' Silver Limited CRD

Secondary fuel filter from wwdiesel
Northstar AGM
GDE Hot Tune
EGR delete
Suncoast TC
Transgo Kit
Carter Intank-pump
SAMCO Hoses
Silicone Intake hose
Silicone Vacuum hoses
Hayden HD Fan Clutch
ARB Front Bumper
Bosch 5V glow plugs
Gen II Fuel Head
Rockfather II Lift
GM 11 Blade fan


Top
 Profile  
 
 Post subject: Re: P1202 sudden
PostPosted: Sun Mar 20, 2022 10:21 pm 
Offline
Moderator
Moderator
User avatar

Joined: Sat Aug 24, 2013 11:36 pm
Posts: 7155
Location: Central GA
timothyd wrote:
I am down to either of these, what seems more likely to try first?
HPFP Fuel Pressure Regulator ???
Fuel Rail Pressure Solenoid (End of fuel rail?)

Please clarify parts nomenclature with location numbers using diagram below to be sure of the parts you are asking about.
Are you asking about parts on the CP3 and the fuel rail or just the fuel rail?

Image

_________________
Supporting Vendor and Moderator of LOST
05 Jeep Liberty CRD Limited :JEEPIN:
Ironman Springs/Bilstein/Shocks
Yeti StgIV Hot Tune
Week's BatteryTray
No FCV/EGR
Samcos/ProVent
SunCoast/Transgo
Carter Intank-pmp
2mic.Sec.Fuel Filter
Flowmaster/NO CAT
V6Airbox/noVH
GM11 Bld.fan/HDClutch
IronrockArms/wwdieselMount

98 Dodge Cummins 24 Valve


Top
 Profile  
 
 Post subject: Re: P1202 sudden
PostPosted: Sun Mar 20, 2022 10:58 pm 
Offline
LOST Newbie

Joined: Wed Feb 20, 2019 2:58 am
Posts: 90
These two parts, they seem to be the most likely culprits but I’m not sure which to try first.

https://www.idparts.com/fuel-rail-press ... 10152.html

https://www.idparts.com/hpfp-fuel-press ... -4591.html

_________________
06' Silver Limited CRD

Secondary fuel filter from wwdiesel
Northstar AGM
GDE Hot Tune
EGR delete
Suncoast TC
Transgo Kit
Carter Intank-pump
SAMCO Hoses
Silicone Intake hose
Silicone Vacuum hoses
Hayden HD Fan Clutch
ARB Front Bumper
Bosch 5V glow plugs
Gen II Fuel Head
Rockfather II Lift
GM 11 Blade fan


Top
 Profile  
 
 Post subject: Re: P1202 sudden
PostPosted: Mon Mar 21, 2022 3:02 am 
Offline
Moderator
Moderator
User avatar

Joined: Sat Aug 24, 2013 11:36 pm
Posts: 7155
Location: Central GA
I would suggest the Fuel Quantity Solenoid (preferred name) that is on the back of the CP3 injection pump first. (Item No. 4 on the diagram I posted)
There have been several reports of it going bad in the past, while reports of the Fuel Pressure Solenoid on the end of the fuel rail failing is extremely rare.

_________________
Supporting Vendor and Moderator of LOST
05 Jeep Liberty CRD Limited :JEEPIN:
Ironman Springs/Bilstein/Shocks
Yeti StgIV Hot Tune
Week's BatteryTray
No FCV/EGR
Samcos/ProVent
SunCoast/Transgo
Carter Intank-pmp
2mic.Sec.Fuel Filter
Flowmaster/NO CAT
V6Airbox/noVH
GM11 Bld.fan/HDClutch
IronrockArms/wwdieselMount

98 Dodge Cummins 24 Valve


Top
 Profile  
 
 Post subject: Re: P1202 sudden
PostPosted: Wed Mar 23, 2022 11:32 pm 
Offline
LOST Newbie

Joined: Wed Feb 20, 2019 2:58 am
Posts: 90
Replaced that sensor and still no change, above 2k rpm and after about 10 seconds the light kicks on.

_________________
06' Silver Limited CRD

Secondary fuel filter from wwdiesel
Northstar AGM
GDE Hot Tune
EGR delete
Suncoast TC
Transgo Kit
Carter Intank-pump
SAMCO Hoses
Silicone Intake hose
Silicone Vacuum hoses
Hayden HD Fan Clutch
ARB Front Bumper
Bosch 5V glow plugs
Gen II Fuel Head
Rockfather II Lift
GM 11 Blade fan


Top
 Profile  
 
 Post subject: Re: P1202 sudden
PostPosted: Thu Mar 24, 2022 9:12 pm 
Offline
LOST Junkie

Joined: Fri Mar 20, 2015 2:11 pm
Posts: 800
Location: markham, ontario
maybe get a helper to keep the rpm above 2000 and you go to wiggle the wire harness and connector at the fuel pressure sensor located at middle of fuel rail. also check all the pins between ecm and connection to the sensor


Top
 Profile  
 
 Post subject: Re: P1202 sudden
PostPosted: Thu Apr 07, 2022 12:33 pm 
Offline
LOST Newbie

Joined: Wed Feb 20, 2019 2:58 am
Posts: 90
Ended up being the Fuel Rail Pressure Solenoid. For future reference, I should have said those fuel rail pressures were in park just revving. It now site at 4-5k idle and only 10k at 2500-3000 rpm. Under actual load I get up to 24k PSI. I also am realizing that I was getting a small amount of black smoke on takeoff which I had not had since the GDE tune and what seemed like a bit of loss of power months before this code showed up. I guess it make sense, if the solenoid is stuck partially open it would be too closed at idle leaving the pressure to high and too open under load bleeding off too much pressure. Also when I took the solenoid out there was some rust around the solenoid valve.

_________________
06' Silver Limited CRD

Secondary fuel filter from wwdiesel
Northstar AGM
GDE Hot Tune
EGR delete
Suncoast TC
Transgo Kit
Carter Intank-pump
SAMCO Hoses
Silicone Intake hose
Silicone Vacuum hoses
Hayden HD Fan Clutch
ARB Front Bumper
Bosch 5V glow plugs
Gen II Fuel Head
Rockfather II Lift
GM 11 Blade fan


Top
 Profile  
 
Display posts from previous:  Sort by  
Post new topic Reply to topic  [ 10 posts ] 

All times are UTC - 5 hours [ DST ]


Who is online

Users browsing this forum: No registered users and 17 guests


You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum

Search for:
Jump to:  
Powered by phpBB © 2000, 2002, 2005, 2007 phpBB Group. Color scheme by ColorizeIt!
Logo by pixeldecals.com