Fuel filter head.

PunisherKJ88 · **Joined:** Thu Nov 05, 2015 9:41 pm **Posts:** 11

I have the 2005 Liberty CRD. The head that the fuel filter screws into, I had one of the electrical connectors break off. It's the one on left. I can't find the part online and the part store wasn't any help. They though it was the water sensor but weren't sure. Any help would be appreciated

Sent from my SM-G935V using Tapatalk

papaindigo · **Posted:** Tue Oct 11, 2016 9:02 am

The actual plug ON the filter head or the plug on the wire. If the former you likely need a new fuel filter assembly-see gen 2 unit at idParts. If it's the plug on the wire it's likely a standard plug that can be sourced on in after market.

PunisherKJ88 · **Joined:** Thu Nov 05, 2015 9:41 pm **Posts:** 11

It's looks like a replaceable sensor on the filter head. But can't find what it is. Here's a couple pics of what I'm talking about.

Sent from my SM-G935V using Tapatalk

flash7210 · **Posted:** Tue Oct 11, 2016 10:01 am

That looks like the fuel temp sensor.
I dont think its available separately.
Its reccomended to replace the entire fuel filter assembly.

PunisherKJ88 · **Joined:** Thu Nov 05, 2015 9:41 pm **Posts:** 11

Going to order the gen 2 head from idParts. Wondering if it's OK to drive short distances till it gets here to replace the head. Thanks for the help

Sent from my SM-G935V using Tapatalk

flash7210 · **Posted:** Tue Oct 11, 2016 10:37 am

Without the sensor in the fuel head, it will leak fuel or allow air into the fuel system. Your engine will run very poorly like that.

PunisherKJ88 · **Joined:** Thu Nov 05, 2015 9:41 pm **Posts:** 11

flash7210 wrote:

Without the sensor in the fuel head, it will leak fuel or allow air into the fuel system. Your engine will run very poorly like that.

The sensor is still in just broke of in the head

Sent from my SM-G935V using Tapatalk

mass-hole · **Posted:** Tue Oct 11, 2016 11:19 am

PunisherKJ88 wrote:

flash7210 wrote:

Without the sensor in the fuel head, it will leak fuel or allow air into the fuel system. Your engine will run very poorly like that.

The sensor is still in just broke of in the head

Sent from my SM-G935V using Tapatalk

As long as its no leaking its fine. If anything it may draw in air being that its under suction.

You may get a code but other than that it should be ok. you could also consider a Racor filter head and 2 micron filter if you feel up to it. It mounts in the stock location but will require a little bit of wiring for the heater, WIF, and temp sensor.

Fuel filter head.

Who is online