LOST JEEPS http://www.lostjeeps.com/forum/phpBB3/ |
|
glow plug http://www.lostjeeps.com/forum/phpBB3/viewtopic.php?f=5&t=89189 |
Page 1 of 1 |
Author: | foxhunter [ Thu Aug 30, 2018 2:25 am ] |
Post subject: | glow plug |
got P1261 code for #1 plug, not wanting to assume anything. is the no. 1 plug the front one? |
Author: | GordnadoCRD [ Thu Aug 30, 2018 4:10 am ] |
Post subject: | Re: glow plug |
Yes. Disconnect the battery. Slip the belt off the alternator, and remove the alternator and the rear support bracket. #1 is just behind and beneath it. It is easy to get to with the alternator removed. |
Author: | k9adv [ Thu Aug 30, 2018 9:32 am ] |
Post subject: | Re: glow plug |
Try to access it before you remove the alternator. I easily did mine with the alternator in there. I did need long pliers to remove the wire initially. |
Author: | WWDiesel [ Thu Aug 30, 2018 12:51 pm ] |
Post subject: | Re: glow plug |
Important! Be sure and soak it real good overnight with a very good penetrating oil like Kano's Kroil oil, PB Blaster, or CRC Freeze-Off Super Penetrant. Most also recommend having the engine warm before attempting to unscrew the glow plug. Best of luck! |
Author: | dskater411 [ Thu Aug 30, 2018 3:19 pm ] |
Post subject: | Re: glow plug |
just remove the rear alternator bracket, 3 bolts, and you should be able to replace it. Trickiest part I think was getting the plug wire back on the new one, but #1 glow plug is a walk in the part compared to #3, consider yourself lucky. |
Author: | Ludi Neethling [ Fri Aug 31, 2018 10:50 am ] |
Post subject: | Re: glow plug |
Take care when pulling the wire connector from the glow plug. Due to the heat and age the hard black insulation on top that looks like a button broke off on my nr. 3 wire connector when I tried to unplug it. The glow plug harness is quite expensive. I could probably have used it like that but it took so much effort to get in there that I replaced it, rather than having to deal with an electrical issue down the road. |
Author: | krb [ Sat Sep 01, 2018 6:36 am ] |
Post subject: | Re: glow plug |
WWDiesel wrote: Important! Be sure and soak it real good overnight with a very good penetrating oil like Kano's Kroil oil, PB Blaster, or CRC Freeze-Off Super Penetrant. Most also recommend having the engine warm before attempting to unscrew the glow plug. Best of luck! X2! I snapped mine off above the threads. Other 3 came out no problem... |
Page 1 of 1 | All times are UTC - 5 hours [ DST ] |
Powered by phpBB © 2000, 2002, 2005, 2007 phpBB Group http://www.phpbb.com/ |