Mrgabesir wrote:
The other day she started, then quit after 10 seconds, then started again after several tries. Same again today, but won’t start back up. I’m guessing it’s a gunked up fuel filter, no lift pump. No new errors (there’s a glow plug error, but that’s been there forever and it isn’t cold here). Fuel is low, but not out. Any recommendations to get her started again? And recommendations for a lift pump? I was going to put a few more gallons in the tank with some fuel system cleaner….
Have you ever replaced the crankshaft position censor, it could be causing your problem?
As to the fuel filter,
Replace the fuel filter, use the manual pump on the filter head to bleed all air out of the system before trying to start. Fill the new fuel filter with fresh clean fuel or Power Service Diesel Kleen fuel system cleaner before installing and bleeding the new filter.
As to an intank fuel pump, there are several options.
If you don't want to modify your current wiring harness from under the rear seat to the top of the fuel tank, you can purchase a turn key ready harness and fuel pump module from SasquatchParts.com.
If you are willing to add two wires to your existing wiring harness from the bulk connector under the rear seat to the top of the new intank fuel pump module,
The wire ends are available from Mouser Electronics:>
See this web page for full install instructions:>
http://www.auerbach.ca/kj/lift_pump/default.htmlWire Terminals: Aptiv APEX (formerly Delphi) 2.8 Series Terminals 16 AWG to 14 AWG Bulk Automotive Connectors.
2 female and 1 male pins required & one 1/4" ring terminal for ground wire to body under rear seat
male, 14-16 gauge wire -- 54001801 (male).
female, 14-16 gauge wire -- 54001800 (female)
Purchase wire ends here:>
https://www.mouser.com/Connectors/Autom ... 28-Series/New intank fuel pump modules can be purchased many places including online, just be sure a get a good quality name brand one, and not a cheap chinaism knockoff.
Personally, I am running the Carter, you can find them online including Amazon. Link:>
Carter Electric Fuel Pump Module Assembly 12V (P76148M)Recommended intank Fuel Pumps:In-tank Lift Pump 2005 Jeep Liberty CRD
Mopar: 5143160AB
Airtex E7181M
CARTER P76148M
Delphi # FG1224
_________________
Supporting Vendor and Moderator of LOST05 Jeep Liberty CRD Limited
Ironman Springs/Bilstein/Shocks
Yeti StgIV Hot Tune
Week's BatteryTray
No FCV/EGR
Samcos/ProVent
SunCoast/Transgo
Carter Intank-pmp
2mic.Sec.Fuel Filter
Flowmaster/NO CAT
V6Airbox/noVH
GM11 Bld.fan/HDClutch
IronrockArms/wwdieselMount98 Dodge Cummins 24 Valve