It is currently Wed Jun 19, 2024 4:18 am

All times are UTC - 5 hours [ DST ]




Post new topic Reply to topic  [ 3 posts ] 
Author Message
 Post subject: Jeep Wrangler CRD Crank No Start - Help
PostPosted: Sun Sep 03, 2023 6:23 am 
Offline
LOST Newbie

Joined: Sun Sep 03, 2023 5:00 am
Posts: 1
Urg.. further to my no Start issue i have now checked all the fuses relays and earth straps. i have also charged the battery. now i did run a Scan on it and found the following:
U113E - Relating to a faulty Intelligent Battery Sensor, I cleared it and came up again... so i actually inspected the IBS and it has a crack in it...
U0298 and U0299 both relating to Lost comms on the Dc Dc convertor module... perhaps also to do with IBS
B210D and B210A low battery voltage detected - perhaps also relating to IBS?
B1630 B162C, B1638 ,B1634 all relating to headlight

To Date I have tried the following:
Replaced diesel fuel Filter
Replaced Oil and - just cause
Checked Fuel rail for fuel by loosening a line
Checked all relays, fuses and earth straps
no red dot on the ignition?
no other codes

when cranking i get a little bit of smoke from the exhaust
when cranking the rpm needle hardly lifts

Starter sounds good
Battery is good
No other codes

Where to next ? please help :oops:


Top
 Profile  
 
 Post subject: Re: Jeep Wrangler CRD Crank No Start - Help
PostPosted: Sun Sep 03, 2023 12:04 pm 
Offline
Moderator
Moderator
User avatar

Joined: Sat Aug 24, 2013 11:36 pm
Posts: 7212
Location: Central GA
You may want to replace the crankshaft sensor, a common problem on these engines. They go bad and don't ever set any DTCs.
Clear the codes and see what comes back.
:POPCORN:

_________________
Supporting Vendor and Moderator of LOST
05 Jeep Liberty CRD Limited :JEEPIN:
Ironman Springs/Bilstein/Shocks
Yeti StgIV Hot Tune
Week's BatteryTray
No FCV/EGR
Samcos/ProVent
SunCoast/Transgo
Carter Intank-pmp
2mic.Sec.Fuel Filter
Flowmaster/NO CAT
V6Airbox/noVH
GM11 Bld.fan/HDClutch
IronrockArms/wwdieselMount

98 Dodge Cummins 24 Valve


Top
 Profile  
 
 Post subject: Re: Jeep Wrangler CRD Crank No Start - Help
PostPosted: Sun Sep 03, 2023 7:43 pm 
Offline
LOST Junkie

Joined: Sat Oct 13, 2018 10:09 pm
Posts: 545
Location: Australia
Could you have a bad earth up near the headlight under the battery? IIRC the IBS is just a temperature sensor so you dont overcharge the battery when its hot.

_________________
Australian KJ CRD 2006


Top
 Profile  
 
Display posts from previous:  Sort by  
Post new topic Reply to topic  [ 3 posts ] 

All times are UTC - 5 hours [ DST ]


Who is online

Users browsing this forum: No registered users and 1 guest


You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum

Search for:
Jump to:  
Powered by phpBB © 2000, 2002, 2005, 2007 phpBB Group. Color scheme by ColorizeIt!
Logo by pixeldecals.com