If not one else chimes in Ill see what I can find in the FSM tomorrow.
| LOST JEEPS http://www.lostjeeps.com/forum/phpBB3/ |
|
| Power Steering Pump http://www.lostjeeps.com/forum/phpBB3/viewtopic.php?f=1&t=25730 |
Page 1 of 1 |
| Author: | Ertsride1 [ Mon Oct 22, 2007 9:05 pm ] |
| Post subject: | Power Steering Pump |
I have a 04 Libby with a weak power steering pump has anyone ever replaced one? Mine is leaking out of the lower connection and in the winter it whines for about 15 minutes until the fluid gets warm. Is there a place to download a free service manual or does someone have a pdf file to send to me? if not does anyone have a scanner and can send that chapter to me via email. I dont have the 150 bucks it takes to acquire one from jeep and have enought to buy a pump. any help would be appreciated please. Thanks Garrett |
|
| Author: | Jeepjeepster [ Mon Oct 22, 2007 9:26 pm ] |
| Post subject: | |
If not one else chimes in Ill see what I can find in the FSM tomorrow.
|
|
| Author: | Joe Jeeper [ Mon Oct 22, 2007 9:53 pm ] |
| Post subject: | Power steering pump |
No problem with the pump, I had the pressure line leak and replaced under warranty. |
|
| Author: | Christopher [ Mon Oct 22, 2007 10:10 pm ] |
| Post subject: | |
I just replaced mine with a remanufactured one a couple days ago due to the cold whinning noise. Pretty easy. Unfortunatley the bearings started skweaking today. Called them up (lifetime warranty on pump) they ordered me a new one. Its one pressure line (open end wrench) one return line (hose clamp) and three mounting bolts and thats it. Actually if you order one from autozone it comes with directions, well at least mine did. The hains manuals are cheap, not as good. But pretty good. Chris |
|
| Author: | myjeepwalks [ Mon Oct 22, 2007 11:10 pm ] |
| Post subject: | |
dumb question but what kind of p/s fluid is needed? Says use Mopar power steering fluid or equivelent? Does this take the clear fluid or the red fluid which is pretty much trans fluid? My fluid is black so i can't tell, my pump is starting to leak but no that bad yet. I hate going to the dealer for stuff they'll charge me $30 a pint. They charge double msrp. 
|
|
| Author: | Christopher [ Wed Oct 24, 2007 4:19 pm ] |
| Post subject: | |
Use ATF+4 Chris |
|
| Author: | Rush345 [ Thu Oct 25, 2007 2:26 am ] |
| Post subject: | Service Manual 2002 |
I don't know if they are the same as a 2002 Sport, if so PM me I have a Genuine Shop Manual. If So I'll have to try to figure out how to get it right on my copier scanner. Let me know, also find ot what the stealership is charging to do the job. Sometime that can be a factor. Good Luck 
|
|
| Author: | jeepgirl0385 [ Thu Oct 25, 2007 11:42 am ] |
| Post subject: | |
Are you still under warrenty? I had a power steering line leak that I was able to get replaced. Of course this was after 4 trips to the dealer and them saying there was nothing wrong, even though I had a puddle every time I parked the thing. It took my bf going in, showing them where the leak was while the Jeep was on the lift for them to find it. But anyways, they did replace it. |
|
| Author: | Christopher [ Thu Oct 25, 2007 2:14 pm ] |
| Post subject: | |
I believe all years on the gassers are the same. It is a pretty easy job. The 2002 manual will have the wrong fluid type though. Chyrsler released a notice in 2004 that superseeds that and our 2002 owner manual that says NOT to use ATF. Chris |
|
| Page 1 of 1 | All times are UTC - 5 hours [ DST ] |
| Powered by phpBB © 2000, 2002, 2005, 2007 phpBB Group http://www.phpbb.com/ |
|