| LOST JEEPS http://www.lostjeeps.com/forum/phpBB3/ |
|
| help with speedometer http://www.lostjeeps.com/forum/phpBB3/viewtopic.php?f=1&t=39537 |
Page 1 of 1 |
| Author: | MiniDevil [ Sat Jan 24, 2009 1:39 pm ] |
| Post subject: | help with speedometer |
hello, i am currently on a road trip and in tennessee on my cell. earlier last year my speedometer stopped working. i took it to a shop and they said theyunplugged the wire and cleaned the connector. it worked fine ever since. now my speedometer isnt working again and id like to know how to clean it or such. any help will b appreciated as my jeep now stalls on offramps and when slowing down... thanks |
|
| Author: | Jeepjeepster [ Sat Jan 24, 2009 3:45 pm ] |
| Post subject: | |
Your problem is probably the actual wiring going into the top of the rear diff. Since the diff is moving around so much the wiring will eventually wear out, gotta replace it. When the dealer messed with the connector they had to move the harness around, this is worked for a little while longer. |
|
| Author: | MiniDevil [ Sat Jan 24, 2009 4:54 pm ] |
| Post subject: | |
any idea how much i can expect that to set me back on monday? |
|
| Author: | afornal [ Sat Jan 24, 2009 10:32 pm ] |
| Post subject: | |
Mine did this as well. I fixed mine for .59 cents the cost for a roll of electrical tape, and she's been working ever since. This is a common issue where the wires rub thru. Easy fix. |
|
| Author: | Christopher [ Sat Jan 24, 2009 10:54 pm ] |
| Post subject: | |
My sensor actually went bad. But as people have stated the wires can short. |
|
| Author: | MiniDevil [ Sun Jan 25, 2009 3:31 am ] |
| Post subject: | |
afornal wrote: Mine did this as well. I fixed mine for .59 cents the cost for a roll of electrical tape, and she's been working ever since. This is a common issue where the wires rub thru. Easy fix.
mind explaining how? id rather repair myself rather than wait til monday and spend extra money. in texas now |
|
| Author: | MiniDevil [ Sat Mar 21, 2009 7:21 am ] |
| Post subject: | |
Well, I had my speedometer 'fixed' but now I am having the same problems again. Could someone by any chance please post instructions and possibly pictures on how to fix the rear differential wires myself? I really don't have the extra cash to be giving to the dealer with the economy the way it is. Any help would be greatly appreciated. |
|
| Author: | Jeepjeepster [ Sat Mar 21, 2009 10:25 am ] |
| Post subject: | |
How did they 'fix' it the last time? Crawl up under the rear of the Jeep and take a look at it. Usually I have pictures of everything but thats one thing that I do not. The sensor comes right out of the top of the center section(pumpkin) so its easy to spot. I do believe you can buy a 'kit' that replaces the connector altogether. Maybe tjkj will chime in, Ive seen him talk about it before. |
|
| Author: | tjkj2002 [ Sat Mar 21, 2009 9:33 pm ] |
| Post subject: | |
When my speedo stopped working the wires inside the connector itself was broken,talk about fun fixing.I ended up cutting the connector off and soldering the wires directly to the pins in the speedo sensor,then filling with RTV to seal it all up. |
|
| Author: | MiniDevil [ Sun Mar 22, 2009 1:38 am ] |
| Post subject: | |
Thanks for the replies... I looked underneath at the wiring and connector and don't see anything offhand to tip me off what the problem is. Would I be looking for a broken wire, or should I be checking the entire line to see if something is grounding out? |
|
| Author: | jdumont [ Sun Mar 22, 2009 7:46 pm ] |
| Post subject: | |
The dealer sells a kit to fix this. I did it on mine last year cause the speedo was jumping around. The wires near that connector are prob broken. I believe the parking brake rubs the wires in addition to the diff moving around and that causes the wires to fracture. I think the repair kit cost around $30. Basically consists of a new connector with 8 or so inches or wire for you to splice in. No biggie. Although I dropped a nice blob of molten solder on my forearm whilst soldering upside down under there. C'est la vie.... |
|
| Author: | MiniDevil [ Sun Mar 22, 2009 8:32 pm ] |
| Post subject: | |
jdumont wrote: The dealer sells a kit to fix this. I did it on mine last year cause the speedo was jumping around. The wires near that connector are prob broken. I believe the parking brake rubs the wires in addition to the diff moving around and that causes the wires to fracture.
I think the repair kit cost around $30. Basically consists of a new connector with 8 or so inches or wire for you to splice in. No biggie. Although I dropped a nice blob of molten solder on my forearm whilst soldering upside down under there. C'est la vie.... Great to know.. a 30 dollar collector to splice in sounds great. Can't go wrong with the color coding. Molten Solder + Skin = Bad |
|
| Page 1 of 1 | All times are UTC - 5 hours [ DST ] |
| Powered by phpBB © 2000, 2002, 2005, 2007 phpBB Group http://www.phpbb.com/ |
|