| LOST JEEPS http://www.lostjeeps.com/forum/phpBB3/ |
|
| 05 rear end leak http://www.lostjeeps.com/forum/phpBB3/viewtopic.php?f=1&t=41318 |
Page 1 of 1 |
| Author: | DryBones [ Wed Mar 18, 2009 9:13 pm ] |
| Post subject: | 05 rear end leak |
Ok guys. I was under tonight taking off the tranny skid for a morning routine service at the dealer and I see that my rear end is soaked! It wasn't that way a couple weeks ago when I did my last oil change. Give me some ideas what I am looking at tonight if possible as I have to see the dealer in the morning. Here are some pics. 
|
|
| Author: | JeepinJarhead03 [ Wed Mar 18, 2009 9:30 pm ] |
| Post subject: | |
the way it's radiated and slung up and out it looks like a pinion seal |
|
| Author: | tjkj2002 [ Wed Mar 18, 2009 9:34 pm ] |
| Post subject: | |
Yep pinion seal,takes about 30mins to replace and about $15 for the seal.You need a in/lbs torque wrench though. |
|
| Author: | DryBones [ Wed Mar 18, 2009 9:35 pm ] |
| Post subject: | |
how much is the dealer going to want to charge me to do it? I am getting my tranny serviced in the a.m. and will get a quote. how long can I drive it like this? |
|
| Author: | tjkj2002 [ Wed Mar 18, 2009 9:38 pm ] |
| Post subject: | |
DryBones wrote: how much is the dealer going to want to charge me to do it? I am getting my tranny serviced in the a.m. and will get a quote. how long can I drive it like this? Check your fluid level,if low add and check often until you get it fixed.Leaving it unfixed for to long can allow junk past that seal and destroy the pinion bearings,that will be $1000,thank you come again  .
|
|
| Author: | DryBones [ Wed Mar 18, 2009 9:40 pm ] |
| Post subject: | |
thanks for the help, anybody want to buy a lift to pay for this repair?
|
|
| Author: | JeepinJarhead03 [ Wed Mar 18, 2009 9:44 pm ] |
| Post subject: | |
theyre prolly gonna wanna charge you 200 bucks for doin the pinion seal, if its anything less than that you've got a good dealer who isn't trying to screw you over and yep, tj's totally right, commonly overlooked aspect of oil leaks they go both ways, oil out, trash/dirt in |
|
| Author: | DryBones [ Wed Mar 18, 2009 9:50 pm ] |
| Post subject: | |
thanks, Would this seal get replaced if i was regearing up to 4.10's? I just got my lift parts and was probably going to 4.10 after the lift. Dang Just Empty Every Pocket! |
|
| Author: | tjkj2002 [ Wed Mar 18, 2009 9:54 pm ] |
| Post subject: | |
DryBones wrote: thanks, Would this seal get replaced if i was regearing up to 4.10's? I just got my lift parts and was probably going to 4.10 after the lift. Dang Just Empty Every Pocket! Yes,as would all the bearings and other seals since all that comes with the master install kits.
|
|
| Author: | DryBones [ Wed Mar 18, 2009 9:56 pm ] |
| Post subject: | |
crap...looks like I eat the repair for now and do the rebuild at a later date. |
|
| Author: | tjkj2002 [ Wed Mar 18, 2009 10:00 pm ] |
| Post subject: | |
DryBones wrote: crap...looks like I eat the repair for now and do the rebuild at a later date. Do not let them replace your rear diff fluid,that is $100 saved alone,if they require it get your own(the correct weight) and have then use it instead of there bulk stuff that is a little overpriced.Having the trash-lok will add alot to the price also,OEM friction modifier is very expensive.
|
|
| Author: | JeepinJarhead03 [ Wed Mar 18, 2009 10:28 pm ] |
| Post subject: | |
the bulk stuff is almost as expensive as the purple goodness isn't it? |
|
| Author: | DryBones [ Wed Mar 18, 2009 10:31 pm ] |
| Post subject: | |
shouldn't they just be able to top off the diff or will it need to be drained for the repair? Can you tell I have no diff experience?
|
|
| Author: | DryBones [ Thu Mar 19, 2009 11:34 am ] |
| Post subject: | |
OK, dealership did the tranny service and replaced the pinion seal. The seal replacement was covered under my Carmax warranty less a $75 deductable so my total bill for everything was only $220. I also got a discount for being a member of the local Jeep club. This dealership is Mod friendly! 
|
|
| Author: | JeepinJarhead03 [ Thu Mar 19, 2009 12:42 pm ] |
| Post subject: | |
well that's not bad 75 buck deductable is pretty much the seal and some labor that's good stuff! i am very happy that everything turned out good for you, it's not so common these days but there are still good guys out there fixin jeeps the dealer here in Greenville is pretty decent.. the one in New Bern on the other hand.. i wouldn't let sharpen a lawn mower blade, ya know how it goes! Glad ya got it fixed! Did they do the rear end service too or ya still gotta do that? I halfway feel like I'm tryin to push these things off on people, but when I swapped my diff cover for a rockcrusher, i put a lubelocker gasket on it now keep in mind, i've been servicing rear ends.. (ok jeeze i already here ThunderbirdJunking typing haha) for years and I have to say i hate using RTV to seal diff covers, i always get a drip of grease across the rtv which ends up breaking down the rtv after i torque everything back down and it ends up leaking, not quite so bad with gasketless tranny pans, but I hate the cork deals too If the lubelocker I bought (was like 11 bucks) last's for a few services, I will feel like it was more than worth it, so far it hasn't seeped a drop, it was easy to put on, it had a high quality feel to it, i wasn't worried about pinching and destroying it, i was very impressed with it and I don't impress easily with products like that I mean most of the diesels i worked on used saltwater and a paintbrush to seal the heads so .. really basic and crude technology there that worked just thought I'd throw it out there, I'm def. going to see if they make other gaskets for say.. the tranny pan and such, if so, and it works as well as the rear diff gasket has.. i'll gladly put the lubelocker decal that came with it on my side window (I'm not one of those decal jockeys hehe) Really glad ya got it fixed, is the other jeep going in next? I'm halfway siding with TJKJ that it might not be just a tranny leak because of the oil-wetness ahead of the tranny but it does look like maybe the tranny pan is leakin a lil bit at the front edge, which i mean, it happens, ya kinda expect it after awhile for reference, how far is that dealer you're using from Raleigh NC? |
|
| Author: | DryBones [ Thu Mar 19, 2009 1:21 pm ] |
| Post subject: | |
Dealer is in Manassas, Virginia and I am going to clean the other one and see if I can tell where it is coming from before taking it in. |
|
| Author: | tjkj2002 [ Thu Mar 19, 2009 2:20 pm ] |
| Post subject: | |
DryBones wrote: OK, dealership did the tranny service and replaced the pinion seal. The seal replacement was covered under my Carmax warranty less a $75 deductable so my total bill for everything was only $220. I also got a discount for being a member of the local Jeep club. This dealership is Mod friendly! That's good news.Everytime I go to a dealership for parts or something I get mobbed.
|
|
| Author: | JeepinJarhead03 [ Thu Mar 19, 2009 2:25 pm ] |
| Post subject: | |
gotta do like i do and steal as many pens that aren't chained down as possible
and ask for a shop rag to wipe your hands and then don't give it back!!!!
they steal i steal everybodies stealin and nooo if im at your shop I don't steal tools, i might accidentally pocket your lighter though, i am a lighter thief, every time i leave someones house I empty my pockets to make sure i don't have 5 lighters that aren't mine |
|
| Page 1 of 1 | All times are UTC - 5 hours [ DST ] |
| Powered by phpBB © 2000, 2002, 2005, 2007 phpBB Group http://www.phpbb.com/ |
|