I changed out the drivers side today, will do the passenger side tomorrow, getting the clevis fork bolt to line up with the LCA was lots of fun - there was about a 3/4" height difference between them (clevis fork lower than LCA connect point). The sway bar where it connects to the LCA has about 3/4" height difference between them when sitting on tires. Can't get the bolt to LCA hole. Any ideas on how to correct this?

Try this it helped me

http://www.lostjeeps.com/forum/phpBB3/viewtopic.php?t=30558&highlight=

_________________
Moab Native
2005 Bright Silver Liberty Sport 4X4
Moab Wheels and 245/75/16 BFG A/T
Rusty's Springs
Al's 4.5 A Arms
3 Ring clevis, 1 ISO
Rancho RSX front and rear

just muscle it into place.. i've heard of some people using tie-down straps.. i believe i used a large screwdriver and small crowbar.. dont worry for some reason my passenger side went much easier!

_________________
2006 Renegade. Completely stock.

I'm partial to the 2x4 myself, but then again, I like brute force...

_________________
+
My opinions & advice are taken at your own risk.
+
2002 Patriot Blue KJ - Coming soon!
2006 Black LJ (Wrangler Unlimited), auto, custom skids, 3.5" Rubicon Express, Aussie D30, Rocker Guards & Cooper AT3 235x85r16
2009 Patriot Blue D2500, 5.7L Hemi, 4x4, Quad Cab
1967 Alberg 37' Masthead rigged Sloop

don't worry about the sway bar until you get both sides done then when its on the ground you can get it reconnected easier. rachet strap works good for pulling in a Frankenlift, or it did on the one I installed. Didn't take any longer than the OME or the Rustys to install

_________________
MUDD'S MOTORSPORT'S We do IFS lift installs ,
03 OVERLAND EDITION /Kilby-Skidrow-Mopar-4XGuard skids/ 2.5 inch TOTAL CONTROL JBA coilovers -JBA Arms/MOABS-31 FALKEN WILDPEAK AT3W / 4.10's etc, 04 Kilimanjaro Edition loaded, plus 05 KJ limited

Yea man this is a HUGE HELP. the pictures that I posted was the best trick that I saw and it took only a few mins to do. but you NEED 2 PEOPLE for this part!

PS:
The pictures are not mine, I just reposted them to help others out.
Also use a floor jack under the lower control arm. That will give you leverage and it will help you out.

_________________
2003 KJ Sport JEEPZILLA Edition
American Flag flying high
Frankenlift removed =(
Moabs and plenty of pin striping
Flexable people don't get bent out of shape!
Current MPG 6" to a gallon
L.O.S.T. # BL065211
www.ItAtYourHome.com