got this 2006 libery crd with factory cruise in march .... cruise has never worked .....is there a comon problem?..... also have EGR ( low flow) code that comes and goes.... i'm new to the crd and to this board.... not new to diesels ( or the internet) ..... please help!

_________________
2006 liberty crd black-n grey ero tc
1995 dodge ram 2500 cummins
1985 ford f-600 8.2l detroit diesel
2005 challenger mt-295 tractor

If you can get a list of the stored fault codes, it will determine if there is a wiring problem. It is possible the cruise control needs to be reset inside the PCM, which a dealer can do or us (just need a DRBIII). With the key on, try just holding the on button for 3-4 seconds to see if the CC light comes on. As for the EGR code, here is our website you can review www.greendieselengineering.com There is plenty of info on how we eliminate EGR issues.

_________________
Providers of wholly developed aftermarket solutions for the KJ CRD.
(248) 977 - 9531

thanks.... no cc ligk indicator... was hoping that the switch was bad or disconnected.... .
can the EGR be removed and cleaned ? i have an EGR low flow code ( forgot the code #)seams like the ports my be coked up ?
again thanks




2006 40k miles , no mods , wifes car....

_________________
2006 liberty crd black-n grey ero tc
1995 dodge ram 2500 cummins
1985 ford f-600 8.2l detroit diesel
2005 challenger mt-295 tractor

I think there is a tsb on this problem. I have read it but do not have at my fingertips. Try holding the cruise on button down for about 20 seconds.

_________________
Mail Rated 2005 Red CRD Sport with large rectangular hole in top right behind the EVIC and above the heated leather seats.
2004 Jetta TDI

ok, tried to hold the on button (and all the buttons) multiple times stil no light and no cruise ..... took the air bag off to check the swtch connections and what not.... all looked good.

EGR problem .... i'm under 50k miles and under 5 years old .... would this be covered under the emmission warranty thru the dealer?


what's the trunaround time to have green diesel reprogram my ECU? cause i certanly do not have the $500 core charge.......

_________________
2006 liberty crd black-n grey ero tc
1995 dodge ram 2500 cummins
1985 ford f-600 8.2l detroit diesel
2005 challenger mt-295 tractor

If you overnight it on a Monday USPS Express, it should be back in your hands on Wednesday. We can also reset the CC inside the ECU if that is where the problem lies.

_________________
Providers of wholly developed aftermarket solutions for the KJ CRD.
(248) 977 - 9531

Check all your lights. I have gone through three tail light bulbs since I've had my 05. Every time a brake light or turn signal bulb fries, The cruise control quits working.

_________________
Manure green 2005 CRD sport4x4, GDE Hot tune, Cat Gut, OE skids, Draw tight hitch, Duramax lift pump, 160K on multiple varieties of fuel, XM radio, Escort live with Redline, fog light mod, GPS, Icom IC7000 all band radio call sign KC9QPF, Grabber AT2s on Soft 8s, FIA grill blanket.

Does this sound dumb to anyone else? Wtf? I have not had a tail light go out yet in 5 years, but I'm glad you told me about this. I use my CC a ton (no tickets in 12 years) and I would have lost my mind if the CC sudenly went out.

_________________
2005 Black KJ Sport CRD,
GDE Full Torque ECO TUNE, GDE Transmission ECO Tune,
Samco British Racing Green Hoses
Build Date 1/05
200k miles.
Original Owner

The roads out here are hard on bulbs, headlights included.

_________________
Manure green 2005 CRD sport4x4, GDE Hot tune, Cat Gut, OE skids, Draw tight hitch, Duramax lift pump, 160K on multiple varieties of fuel, XM radio, Escort live with Redline, fog light mod, GPS, Icom IC7000 all band radio call sign KC9QPF, Grabber AT2s on Soft 8s, FIA grill blanket.

In the past I've installed CC's on cars and it's common to use the switched side of the brake lights to kick it off when you hit the brake. So it's not dumb
I observed 3 cars, one a KJ, with the left brake light out yesterday within half an hour Why the LEFT on all three

But the CC light still should be on.

I recall some having cc problems caused by the clock spring.

_________________
Atlantic Blue 06 CRD Limited (his)
Joined by a 2000 XJ Classic (hers)