| LOST JEEPS http://www.lostjeeps.com/forum/phpBB3/ |
|
| Technical Service Bulletin #??? http://www.lostjeeps.com/forum/phpBB3/viewtopic.php?f=5&t=64677 |
Page 1 of 1 |
| Author: | MaineSleddah [ Sat Jan 14, 2012 4:12 pm ] |
| Post subject: | Technical Service Bulletin #??? |
My CRD has 77k miles and the transmission lines are leaking like a sieve under the radiator. I hear there is a Technical Service Bulletin addressing this problem. Doe anyone know what the bulletin number is and what it consists of? How much can I expect to pay to have it done? |
|
| Author: | dkenny [ Sat Jan 14, 2012 5:07 pm ] |
| Post subject: | Re: Technical Service Bulletin #??? |
wow..never heard of this before. I wouldn't think there is a TSB.. did they rust through?? any tranny shop should be able to make new ones.. I replaced some leaking lines in my bus with PEX pipe..yes a temporary solution..but these lines are not high pressure lines. -dkenny |
|
| Author: | racertracer [ Sat Jan 14, 2012 6:37 pm ] |
| Post subject: | Re: Technical Service Bulletin #??? |
MaineSleddah wrote: My CRD has 77k miles and the transmission lines are leaking like a sieve under the radiator. I hear there is a Technical Service Bulletin addressing this problem. Doe anyone know what the bulletin number is and what it consists of? How much can I expect to pay to have it done? when my CRD went in for service in october, the mechanic removed the lines.... did whatever to the connections near the radiator re-attached them and now I am leak free. Cost was zero since he was doing work in there anyway. Don't ask me what the cause was becasuse I didn't ask, it was the least of my worries, all he said was that he detached them, cleaned the connections and reattached them. |
|
| Author: | DOC4444 [ Sun Jan 15, 2012 10:27 am ] |
| Post subject: | Re: Technical Service Bulletin #??? |
Just had leaking trans lines replaced when in for alternator decoupler repair. However, because it was covered by the ESP, there was no charge, so I cannot tell you what it may cost out of pocket. DOC |
|
| Author: | MaineSleddah [ Sun Jan 15, 2012 5:03 pm ] |
| Post subject: | Re: Technical Service Bulletin #??? |
Yes the lines rusted under the cooler. There is a piece of rubber over the lines, perhaps to protect them, and they rusted where the rubber meets the tube... My mechanic says there was a Technical Service Bulletin for line replacement, two filters get replaced and the entire system gets flushed as well... Towing, diag and work, $950... It all started when I drove to the end of the driveway and went to pull out and it would not move. Neither forward or backwards. Transmission fluid was bubbly. Bad sign, sucking air somewhere. I knew the lines were leaking, but had not got to it yet. Hope that takes care of it. |
|
| Author: | MaineSleddah [ Wed Jan 18, 2012 4:22 pm ] |
| Post subject: | update: Technical Service Bulletin is 21-007-07 |
Now that my Liberty is home, I have an actual copy of the service bulletin. It's number 21-007-06, group "transmission" and dated April 07, 2006. It supersedes SB 21-016-05, dated September 01, 2005. Bottom line, the Jeep is running fine again. I guess it has been getting progressively worse, because wow is it responsive now! Cost was $782. |
|
| Author: | racertracer [ Wed Jan 18, 2012 4:31 pm ] |
| Post subject: | Re: update: Technical Service Bulletin is 21-007-07 |
MaineSleddah wrote: Now that my Liberty is home, I have an actual copy of the service bulletin. It's number 21-007-06, group "transmission" and dated April 07, 2006. It supersedes SB 21-016-05, dated September 01, 2005. Bottom line, the Jeep is running fine again. I guess it has been getting progressively worse, because wow is it responsive now! Cost was $782. Did the dealer update the ECU with the latest software update? |
|
| Author: | MaineSleddah [ Thu Jan 26, 2012 12:36 pm ] |
| Post subject: | Re: Technical Service Bulletin #??? |
That would be a big NO. It did not go to a dealer, rather a new found auto repair shop that does diesels too. I was quite pleased with their work. Anyone in southern Maine looking for a good shop, drop me a pm. |
|
| Page 1 of 1 | All times are UTC - 5 hours [ DST ] |
| Powered by phpBB © 2000, 2002, 2005, 2007 phpBB Group http://www.phpbb.com/ |
|