It's not the decoupler pulley... maybe air in the fuel, or maybe the ORM will fix it?
I will check the tensioner during the timing belt.
| LOST JEEPS http://www.lostjeeps.com/forum/phpBB3/ |
|
| Squeal like a pig my little CRD! http://www.lostjeeps.com/forum/phpBB3/viewtopic.php?f=5&t=69471 |
Page 1 of 1 |
| Author: | Rich [ Thu Jul 05, 2012 2:46 pm ] |
| Post subject: | Squeal like a pig my little CRD! |
I have been getting a loud squeal from the engine bay for a while now. It only occurs when the engine is under load beyond 2000rpm, and at the last bit of revolution during shutdown. I have no other symptoms. Serp belt was replaced with no change to the squeal, Alt was replaced as well. Any thoughts? |
|
| Author: | Randy B [ Thu Jul 05, 2012 3:30 pm ] |
| Post subject: | Re: Squeal like a pig my little CRD! |
I would check the serp. tensioning pulley |
|
| Author: | ibedonc [ Thu Jul 05, 2012 3:53 pm ] |
| Post subject: | Re: Squeal like a pig my little CRD! |
rubbing the power steering pulley |
|
| Author: | Rich [ Thu Jul 05, 2012 4:03 pm ] |
| Post subject: | Re: Squeal like a pig my little CRD! |
ibedonc wrote: rubbing the power steering pulley What is rubbing the PS pulley? |
|
| Author: | papaindigo [ Thu Jul 05, 2012 4:15 pm ] |
| Post subject: | Re: Squeal like a pig my little CRD! |
Chuckle if it was a Dodge D250 Cummins I'd tell you, from looong experience, that's the stock shutdown noise. I suspect your serp belt tensioner may be weak or dying. It's not uncommon for a bad serp belt tensioner to "lean" to the side and impinge on the power steering pump, sometimes so badly as to make one think the power steering pump is frozen, see recent chat to that effect. Is it a prolonged squeal of a brief chirp? |
|
| Author: | geordi [ Thu Jul 05, 2012 4:24 pm ] |
| Post subject: | Re: Squeal like a pig my little CRD! |
Something is leaning somewhere - Also check on the bolts for the alternator. You might want to actually remove them entirely to be sure, mine looked just fine, but in fact, 2 of the three (the bottom two) had completely sheared off and the alternator was *just enough* out of position to be howling in a similar fashion. |
|
| Author: | Rich [ Thu Jul 05, 2012 10:15 pm ] |
| Post subject: | Re: Squeal like a pig my little CRD! |
Here is the sound of the shut down, for obvious reasons I can't duplicate the 2k+, but it is very similar in pitch/tone. The sound occurs any time the engine is under load beyond 2k, or anytime there is a drastic increase in engine RPM. http://smg.photobucket.com/albums/v391/ ... I_0325.mp4 Is there a way to test the tensioner for proper function? I am pulling the nose apart next week for a timing belt and water pump, so I can easily test it while I am in there. BTW, CRD has 102,xxx miles. |
|
| Author: | Hexus [ Mon Jul 09, 2012 10:41 pm ] |
| Post subject: | Re: Squeal like a pig my little CRD! |
Mine made a similar noise about 5 times before the Alternator went out. May not be your issue, but it was mine. |
|
| Author: | BlackLibertyCRD [ Tue Jul 10, 2012 12:52 am ] |
| Post subject: | Re: Squeal like a pig my little CRD! |
decoupler pulley is bad. I replaced a customer pulley for same noise on shutdown. |
|
| Author: | jkbkwarner [ Tue Jul 10, 2012 1:17 pm ] |
| Post subject: | Re: Squeal like a pig my little CRD! |
I had a noisy chirping and it was the decoupler. That noise was constant at idle. So at higher RPM the pitch would probably change to out-of-human hearing range or general engine noise rose above it for me. |
|
| Author: | Rich [ Tue Jul 10, 2012 2:03 pm ] |
| Post subject: | Re: Squeal like a pig my little CRD! |
It's not the decoupler pulley... maybe air in the fuel, or maybe the ORM will fix it? I will check the tensioner during the timing belt. |
|
| Author: | ibedonc [ Tue Jul 10, 2012 2:58 pm ] |
| Post subject: | Re: Squeal like a pig my little CRD! |
Rich wrote: ibedonc wrote: rubbing the power steering pulley What is rubbing the PS pulley? serp. tensioning pulley |
|
| Page 1 of 1 | All times are UTC - 5 hours [ DST ] |
| Powered by phpBB © 2000, 2002, 2005, 2007 phpBB Group http://www.phpbb.com/ |
|