LOST JEEPS
http://www.lostjeeps.com/forum/phpBB3/

new muffler needed
http://www.lostjeeps.com/forum/phpBB3/viewtopic.php?f=5&t=78518		 Page 1 of 1
Author:  bronco9588 [ Sat Mar 08, 2014 9:24 pm ]
Post subject:  new muffler needed
hey guys... while working on my car today I noticed black soot by the seam of the muffler. I figure a little jb weld might get me a couple more months, but is just a "patch." I am also moving to Hawaii and don't want to pay a fortune for parts and labor over there. It looks like now is a good time to deal with the problem.

I want something that is really easy to bolt on with no welding required. I also would love to see some MPG gains. Is there a good solution out there that meets these needs. Did a quick google and forum search already...
Author:  bugnout [ Sat Mar 08, 2014 10:21 pm ]
Post subject:  Re: new muffler needed
You don't need a muffler, Straight pipe it.
Author:  jeepdan [ Sat Mar 08, 2014 10:49 pm ]
Post subject:  Re: new muffler needed
bugnout wrote:
You don't need a muffler, Straight pipe it.

Better check your State laws before you do something like that.
You don't want to have to do it over again.
Author:  WWDiesel [ Sun Mar 09, 2014 11:43 am ]
Post subject:  Re: new muffler needed
I installed a flowmaster, very happy with results and sound! :BANANA:
Bought it a Advance Auto Parts and price was good! :wink:
Author:  bronco9588 [ Mon Mar 10, 2014 9:23 am ]
Post subject:  Re: new muffler needed
See any mpg increase? Did you reuse your tailpipe?
Author:  WWDiesel [ Mon Mar 10, 2014 11:57 am ]
Post subject:  Re: new muffler needed
bronco9588 wrote:
See any mpg increase? Did you reuse your tailpipe?

Yes, some power and slight mileage increase. Replaced CAT with stright pipe, reused tailpipe as it was ok... :SOMBRERO:
Author:  bugnout [ Mon Mar 10, 2014 1:49 pm ]
Post subject:  Re: new muffler needed
WWDiesel wrote:
bronco9588 wrote:
See any mpg increase? Did you reuse your tailpipe?

Yes, some power and slight mileage increase. Replaced CAT with stright pipe, reused tailpipe as it was ok... :SOMBRERO:

Same here, reused tailpipe welded to straight pipe that connects like stock at the flange behind the cat. Slight increase in power and mpg, not appreciable louder, in fact my wife didn't notice the change and she typically notices.
Author:  DOC4444 [ Mon Mar 10, 2014 3:21 pm ]
Post subject:  Re: new muffler needed
I would not remove CAT "can" because it could be a problem at state inspection. Several have "cleaned" it out (about $200 of material inside) but GDE insists that there is no performance advantage to this. Muffler can be eliminated.

DOC
Author:  WWDiesel [ Mon Mar 10, 2014 4:01 pm ]
Post subject:  Re: new muffler needed
Any exhaust flow restrictions removed on the exhaust side of a diesel motor increases performance! On my Dodge I got a 5 inch turbo back exhaust system.
But as Doc stated, if you have inspection requirements, you may not want to remove CAT. We have no inspections at my location.... :JEEPIN:
Author:  papaindigo [ Mon Mar 10, 2014 4:55 pm ]
Post subject:  Re: new muffler needed
I'll leave to others to speculate on the merits of opening up the exhaust, I know it works on gassers but I don't know about diesels, and simply note that the narrowest point in the system is right where the exhaust meets the turbo outlet followed by the point where the exhaust pipe curves back to the rear of the vehicle and then the exhaust, IIRC, flange. If you are installing a new muffler you probably won't find an exact fit and welding in a short piece to get rid of that restrictive muffler flange probably is a good idea.

What I can say for sure is that if you remove your CAT do not discard it. Local regulations may change, your location may change, or you may sell to someone in an area that needs the CAT even if it's gutted. There have been 2-3 forum members who found themselves in desperate need to a CAT that they had previously disposed of.
Page 1 of 1 All times are UTC - 5 hours [ DST ]
Powered by phpBB © 2000, 2002, 2005, 2007 phpBB Group
http://www.phpbb.com/