| LOST JEEPS http://www.lostjeeps.com/forum/phpBB3/ |
|
| Water Pipe That Bolts to Rear Cover for Timing Belt http://www.lostjeeps.com/forum/phpBB3/viewtopic.php?f=5&t=81927 |
Page 1 of 1 |
| Author: | buttermilkmeeks [ Sat Apr 25, 2015 11:47 pm ] |
| Post subject: | Water Pipe That Bolts to Rear Cover for Timing Belt |
Hello all! First post. You guys have been a wonderful resource and I just put on a new timing belt, water pump, and thermostat thanks to all of the write ups here (and especially thanks to Sir Sam's write-up and great YouTube videos). The job was a success - except for a little snafu in which I gouged a hole into the water pipe that runs across the top of the engine and bolts to the rear cover of the timing belt housing. So I am going to have to replace this pipe and I have had trouble finding an accurate description of the pipe or a part number. I am looking through the service manual as well as the parts fiche, but hoping someone here can help me ID the pipe so I can get my Liberty back on the road as soon as possible. Any ideas? |
|
| Author: | Hexus [ Sun Apr 26, 2015 12:25 am ] |
| Post subject: | Re: Water Pipe That Bolts to Rear Cover for Timing Belt |
Are you talking about the Heater Core hose? Overflow hose (PN 05086496AA) runs from the drivers side of the radiator back to the coolant reservoir. |
|
| Author: | Hexus [ Sun Apr 26, 2015 12:34 am ] |
| Post subject: | Re: Water Pipe That Bolts to Rear Cover for Timing Belt |
Take a picture of the hose in question and post it. |
|
| Author: | buttermilkmeeks [ Sun Apr 26, 2015 8:38 am ] |
| Post subject: | Re: Water Pipe That Bolts to Rear Cover for Timing Belt |
In the interest of time, I stole this picture from Sir Sam's write-up and circled the pipe in red:  The rubber connector hose running from the pipe back down to the Water Pump adaptor is missing in this picture. (If I am interpreting my parts schematic fiche correctly.) The pipe originates near the lower end of the back of the driver side of the engine block. I will post another picture later today if necessary. I hope to get the part today, but suspect I will have to order it from out-of-town. |
|
| Author: | WWDiesel [ Sun Apr 26, 2015 10:09 am ] |
| Post subject: | Re: Water Pipe That Bolts to Rear Cover for Timing Belt |
It is the EGR coolant line coming from the EGR cooler outlet. You can just cut the line and put it back together with a piece of heater hose and two screw clamps. It has less than 16 lbs pressure on it.  edit: OEM part numbers for pipe, EGR water return pipe - 05142584AB; 05142584AA |
|
| Author: | Squeeto [ Mon Apr 27, 2015 10:41 am ] |
| Post subject: | Re: Water Pipe That Bolts to Rear Cover for Timing Belt |
WWDiesel wrote: OEM part numbers for pipe, EGR water return pipe - 05142584AB; 05142584AA How much to replace this from the dealer? Maybe remove it and buy a delete kit. |
|
| Author: | buttermilkmeeks [ Mon Apr 27, 2015 1:17 pm ] |
| Post subject: | Re: Water Pipe That Bolts to Rear Cover for Timing Belt |
Thank you WWDiesel! I cut the line and clamped a hose on top of the hole. Everything appears to be in working order. |
|
| Page 1 of 1 | All times are UTC - 5 hours [ DST ] |
| Powered by phpBB © 2000, 2002, 2005, 2007 phpBB Group http://www.phpbb.com/ |
|