LOST JEEPS
http://www.lostjeeps.com/forum/phpBB3/

No odometer
http://www.lostjeeps.com/forum/phpBB3/viewtopic.php?f=5&t=83731		 Page 1 of 1
Author:  Diver1430 [ Sat Dec 26, 2015 6:19 pm ]
Post subject:  No odometer
Speedometer works, no odometer. Perhaps diff plug or sensors?
Author:  jws84_02 [ Sat Dec 26, 2015 6:23 pm ]
Post subject:  Re: No odometer
Is your abs and brake light on?
Author:  olypopper [ Sun Dec 27, 2015 12:34 am ]
Post subject:  Re: No odometer
My symptoms were just like yours and the problem ended up being a broken wire at the rear wheel speed sensor. Mopar has a high quality kit to repair and upgrade to a larger diameter wire.
Author:  Billwill [ Sun Dec 27, 2015 3:15 am ]
Post subject:  Re: No odometer
Diver1430 wrote:
Speedometer works, no odometer. Perhaps diff plug or sensors?


What year is your CRD?

Newer models pick up the speed from the wheel sensors...early models picked up speed and Odometer from the sensor on the rear diff. So olypopper probably has the right answer for you :?
Author:  WWDiesel [ Sun Dec 27, 2015 12:37 pm ]
Post subject:  Re: No odometer
olypopper wrote:
Mopar has a high quality kit to repair and upgrade to a larger diameter wire.

Mopar part number for the upgrade kit?
Found these part numbers, if not correct, please advise?

Rear Speed Sensor:
56041393AA

Wiring Upgrade Kit for speed sensor:
Mopar Part# 05014002AA
Industry Part # DK44956W
Author:  Diver1430 [ Sun Dec 27, 2015 6:24 pm ]
Post subject:  Re: No odometer
It s a 2005, the brake light and abs light is on. I put new rotors on a few months ago along with new pads. But I think they have been on for awhile. Is it the driver or passenger side?
Author:  flash7210 [ Sun Dec 27, 2015 7:39 pm ]
Post subject:  Re: No odometer
Diver1430 wrote:
It s a 2005, the brake light and abs light is on. I put new rotors on a few months ago along with new pads. But I think they have been on for awhile. Is it the driver or passenger side?


There is no way to tell.
Best you can do is remove both front wheels and inspect the ABS sensor wires for damage.
Im pretty sure both left and right sensor are the same.
Author:  jws84_02 [ Mon Dec 28, 2015 10:01 am ]
Post subject:  Re: No odometer
Op, check right on top of your rear diff. I'm gonna bet the wires to the sensor have either broke or frayed.
Author:  olypopper [ Mon Dec 28, 2015 1:51 pm ]
Post subject:  Re: No odometer
WWDiesel wrote:
olypopper wrote:
Mopar has a high quality kit to repair and upgrade to a larger diameter wire.

Mopar part number for the upgrade kit?
Found these part numbers, if not correct, please advise?

Rear Speed Sensor:
56028187AE

Wiring Upgrade Kit for speed sensor:
Mopar Part# 05014002AA
Industry Part # DK44956W


Part numbers that I just installed were
56041393AA for the rear wheel speed sensor
5013995AA for the wiring kit
Author:  Billwill [ Tue Dec 29, 2015 2:37 am ]
Post subject:  Re: No odometer
Diver1430 wrote:
It s a 2005, the brake light and abs light is on. I put new rotors on a few months ago along with new pads. But I think they have been on for awhile. Is it the driver or passenger side?


There is a TSB for all 2005 KJs....gas and diesel...that the rear diffs may have been filled with the wrong type of oil at the factory. This oil eats up the speed sensor on the rear diff. Dealers are supposed to drain, flush and replace the diff oil and fit a new sensor. I will try and find this TSB if I can. I gather that the 2005 uses three sensors for ABS, two for the front wheels and the sensor on the rear diff.

If you do not find frayed wires to the diff sensor and you have not replaced the diff oil I would suggest you drain and refill the diff oil and replace the diff sensor or talk to the Dealers. :?
Author:  Billwill [ Wed Dec 30, 2015 8:01 am ]
Post subject:  Re: No odometer
OK here is the link to the TSB for 2005 rear diff sensor:

http://www.jeepkj.com/forum/f212/tsb-08-048-05-differential-mounted-rear-wheel-speed-sensor-27665/
Author:  olypopper [ Thu Dec 31, 2015 12:26 pm ]
Post subject:  Re: No odometer
The TSB may still apply but is out dated by now. The new speed sensor part number that I listed is most current and comes with the oring installed.
Author:  Diver1430 [ Thu Dec 31, 2015 4:10 pm ]
Post subject:  Re: No odometer
Tks all, this problem is on crd2, crd1 is in my garage with a a loss of power and no shift up for the last two gears. It s interesting that the abs sensors and the diff sensor are also possible candidates for that issue. The Wx stinks so I ll just have to wait since I can live with a few lights and no odometer. But I ll need. to go to the dealer in brownsville and order the parts. Always takes a week. I ve cked the servo actuator with a vac pump and it s moving ok. Next to bypass the relay. (For the power part of the problem, but curiously, they both occurred on the same day).
Page 1 of 1 All times are UTC - 5 hours [ DST ]
Powered by phpBB © 2000, 2002, 2005, 2007 phpBB Group
http://www.phpbb.com/