I recently had a strange thing happen... The bolts holding the flex plate to the torque converter loosened and sheared off, leaving me stranded. I tried drilling the bolts out of the TC, but I can't get em out, so I just bought a new one (and a new flex plate). The used Suncoast is now for sale for less than half price, including standard shipping anywhere in the US, $400

_________________
2006 Liberty CRD Limited @185k
GDE Eco tune engine/trans
Samcos
Provent
Suncoast TC
Weeks Stage 2
3.7 airbox
5v bosch glow plugs
3" RRO lift/JBA upper A-arms
Steel roof rails/rack
Toyo Open Country ATIII 245/75r16
RRO kicker sliders
ARB lockers
Beefier brakes
NEXT ON THE LIST...
ARB Front bumper
WAM rear bumper
Skid plates

You probably wont get much interest unless you include a pic or 2 showing the damage.

_________________
Australian KJ CRD 2006

Happened to me too. And I know I used loctite on the bolts and torqued to spec. Yours is about the 10th one I have heard of happening, specifically with suncoast. I think the aluminum threads are to blame. I didn't put mine back in either. Went with Florida TC. If you have a suncoast you better be checking your bolts regularly.

_________________
05CRD: GDE Hot ECU & TCM tunes, Provent, Cat filter, Facet lift pump, TransGo kit, Florida TC, Samcos, stainless brake lines, HDS thermostat, Renegade light bar,
Bilstein adjustables, Al's Gen 4.5 Arms, 235/85-16 Duratracs, DTT rear, Elocker front, EVIC+TPMS, Turbo timer, McNally pillar gauges, Weeks Stage II kit.

Not true for everyone! Mine has had the SunCoast installed in 2013 (7 years ago) and have never had any problems or issues even when pulling 4-5k trailer loads.

_________________
Supporting Vendor and Moderator of LOST
05 Jeep Liberty CRD Limited
Ironman Springs/Bilstein/Shocks
Yeti StgIV Hot Tune
Week's BatteryTray
No FCV/EGR
Samcos/ProVent
SunCoast/Transgo
Carter Intank-pmp
2mic.Sec.Fuel Filter
Flowmaster/NO CAT
V6Airbox/noVH
GM11 Bld.fan/HDClutch
IronrockArms/wwdieselMount
98 Dodge Cummins 24 Valve

Mine was in for 10 years. 2008 - 2018. Check your bolts.

_________________
05CRD: GDE Hot ECU & TCM tunes, Provent, Cat filter, Facet lift pump, TransGo kit, Florida TC, Samcos, stainless brake lines, HDS thermostat, Renegade light bar,
Bilstein adjustables, Al's Gen 4.5 Arms, 235/85-16 Duratracs, DTT rear, Elocker front, EVIC+TPMS, Turbo timer, McNally pillar gauges, Weeks Stage II kit.

Mine isn’t aluminum it looks like billet steel.

_________________
2005 limited, tinted, OME lift, falken wildpeak 245/75-16, Suncoast, Transgo, Chevy fan+clutch, 195° Kap Stat Mod, Derale tranny cooler, Provent, Stage 2 tune, EGRdelete, Cat delete, Group65 batt, V6 airbox, tow brakes, switchblade key, DIY roof rack, DIY Front bumper,
Future; rear bumper, true tracs, tank fuel pump, webasto heater, 5sp manual