dieselsmoke wrote:
The only thing I am worried about is floating the valves.....Anyone float their valves yet?
My valves did not float at 5,000 RPM. This happened when my trans had a very brief air bubble disconnect after doing the Transgo SunCoast upgrade on my first test drive. The fluid in the pan (10 Qts) dropped too low when I punched it to pull away from a tail gating Cadillac. I still blew away the Cadillac but seeing the tach at 5K is not easing. The dip stick said it was full at 10 Qts with the engine running when I started off on my first test drive, after that I went back home and added more fluid, drove some more and added some more. When I got up to 17 Quarts in the trans with my extra deep PML pan like they use on the 68RFE trans, it was happy. I heard the standard pan takes 13 Quarts after the Transgo/SunCosast swap.
Years ago Mercedes got one of their 6 Cylinded IDI engines up to 6K for a race application. I am sure the new racing diesels can go higher, and I bet someone here would know. But I bet the ECMs are mapped to advance the timing enough to compensate. I don't know the limit on our CRDs.
dieselsmoke, I think you better hunt down the Rocket Chip guy and twist his arm, I don't think Keith can give you all the HP you want. Ron Wolverton can fix you up with the 800 HP 68RFE clutch pack and the big input shaft with a double disk lock up clutch Torque Converter. All of this will drop into your 545RFE (I passed this one up). Then you better get a Dana 3.73:1 3/4 ton or 1 ton rear end so you don't twist off the rear axle shafts. Since you have the '05 you can put the rear ABS sensor onto the Dana 3/4 ton rear end too. Better go with the Jeepin' Al steel front axle while your at it so you don't split open the case.
Will you be the first with a Dully CRD?
OH ya, replace the Glow Plugs with Plasma Igniters, something a Future Generation of Diesels will have.
Then you will need all of the drive train components above including the rear duals.