Got the Suncoast TC and pump.
Put them together... they fit....
Now to put em in the tranny !

_________________
----------------------------------------------------------------------
06 CRD LTD - Suncoast TC- Shift Kit - Spicer UJ - FRKNLIFT - F37 - Magnaflow - 22.0 City - 24@65MPH - Fumoto F-102 - AUX T Cooler - Tank Lift Pump

Good show - now, if you wouldn't mind, flip the pump over and take a few clear shots of the modified hub area - the pics in the original post are quite blurry - please and thank you.....................

_________________
'05 CRD Limited
Pricol EGT, Boost
GDE Hot '11; EDGE Trail switched
SEGR; Provent; Magnaflow;
Suncoast T\C, Transgo Tow'n'Go switch;
Cummins LP module, Fleetguard filter, Filterminder
2.5" Daystar f, OME r; Ranchos; K80767's, Al's lifted uppers
Rubicons, 2.55 Goodyears
Four in a row really makes it go

Sure thang, GMCTD..... any other shots?

_________________
----------------------------------------------------------------------
06 CRD LTD - Suncoast TC- Shift Kit - Spicer UJ - FRKNLIFT - F37 - Magnaflow - 22.0 City - 24@65MPH - Fumoto F-102 - AUX T Cooler - Tank Lift Pump

Prolly wouldn't hurt to get a couple shots of the original pump showing the unmodified hub, for comparo

_________________
'05 CRD Limited
Pricol EGT, Boost
GDE Hot '11; EDGE Trail switched
SEGR; Provent; Magnaflow;
Suncoast T\C, Transgo Tow'n'Go switch;
Cummins LP module, Fleetguard filter, Filterminder
2.5" Daystar f, OME r; Ranchos; K80767's, Al's lifted uppers
Rubicons, 2.55 Goodyears
Four in a row really makes it go

Here are the details of the redesigned RFE 545 pump
Sorry, GMCTD , have not pulled the old one out yet

_________________
----------------------------------------------------------------------
06 CRD LTD - Suncoast TC- Shift Kit - Spicer UJ - FRKNLIFT - F37 - Magnaflow - 22.0 City - 24@65MPH - Fumoto F-102 - AUX T Cooler - Tank Lift Pump

I have the original full resolution shots at;

http://picasaweb.google.com/bill.barg/2 ... nnyHighRes

for the picky ones like you-know-who !

_________________
----------------------------------------------------------------------
06 CRD LTD - Suncoast TC- Shift Kit - Spicer UJ - FRKNLIFT - F37 - Magnaflow - 22.0 City - 24@65MPH - Fumoto F-102 - AUX T Cooler - Tank Lift Pump

purdy for a slush box

_________________
2008 KK Liberty Sport NIGHT OPS EDITION + GILLS
OEM & Custom Skids - Factory Tow Package - Rock Lizard Skink Super Sliders
Prototype JBA 4 Inch Lift - JBA UCA's - Flowmaster Super 44 OR - Whacked Resonator
Jet Stage 2 - RL Gecko Basket Rack - Custom Winch Bumper - Recon 10.5K Winch

ready to swap to a manual?

_________________
http://www.Colorado4Wheel.com
"Its not about what you can DO with your Jeep, its about where you can GO with your Jeep."
Knowledgeable - But Caustic

Yes. Manual would be nice..... real nice.
But , you live with what ya got, no?

_________________
----------------------------------------------------------------------
06 CRD LTD - Suncoast TC- Shift Kit - Spicer UJ - FRKNLIFT - F37 - Magnaflow - 22.0 City - 24@65MPH - Fumoto F-102 - AUX T Cooler - Tank Lift Pump

Now, that is some clear - nice shots, Bill - as you can see, that is a new original casting, not the old original casting with the hub\collar removed by fly-cuttting - the large round cover now seals to the case and the torque convertor drive hub - those flat round shiny areas in the casting on either side of the stator shaft are the pins for the two pump gears - the pump is a dual-gear dual-output design - the TCM runs the output of both gears at low engine rpm to get good line pressure\volume, then a valve bypasses the secondary gear, running on the primary gear only as pump pressure increases due to increasing input rpm - some shudder can be caused as the secondary gear is valved in\out

You might disassemble the oem pump for some show'n'tell, if you have some time - that's all those torx stove bolts - I've been trying to purchase a pre-owned original-design pump for show'n'tell, incl machining off the hub for re-use, but no luck

That 52119559 is the p\n for the cover\front seal, needed when installing the TC on a used pump

_________________
'05 CRD Limited
Pricol EGT, Boost
GDE Hot '11; EDGE Trail switched
SEGR; Provent; Magnaflow;
Suncoast T\C, Transgo Tow'n'Go switch;
Cummins LP module, Fleetguard filter, Filterminder
2.5" Daystar f, OME r; Ranchos; K80767's, Al's lifted uppers
Rubicons, 2.55 Goodyears
Four in a row really makes it go

Ya, it would be interesting to know if
1. The pump is identical , minus the boss
2. if the new cover is available as a solo part

I PMed you re: quest for pump

_________________
----------------------------------------------------------------------
06 CRD LTD - Suncoast TC- Shift Kit - Spicer UJ - FRKNLIFT - F37 - Magnaflow - 22.0 City - 24@65MPH - Fumoto F-102 - AUX T Cooler - Tank Lift Pump