My brothers CRD seems to have killed the block heater. Any ideas where I can find a replacement.

Thanks.


Tom

_________________
2006 KJ CRD Ltd - Suncoast, GDE Eco, EGR Delete, After market T-Stat, Skid Row skids, V6 airbox, 2.5" Turbo back
2005 KJ CRD Sport-Suncoast, Transco, GDE Hot-GDE Trans, EGR Delete, Skid Row skids, V6 airbox, 2.5" Turbo back, After market S-Stat
1987 Suzuki LWB Samurai -diesel powered, custom 4 link coil suspension 38.5 SX Swampers

I did a little searching and came up with this part number: 56044738AA. It looks like there are a bunch of dodge vehicles that use it including the gasser version of the liberty. Napa had one for $25, but didn't specifically mention the diesel engine. Otherwise, there are plenty of online dealers that have it for $50ish.

_________________
2005 Liberty CRD Limited
DIY Garage Remanufactured Engine with GDE Full Torque Eco Tune from mile zero.
ARP Studs
Cummins Lift Pump
Transgo HD2 Reprogramming Kit
DIY Rebuilt Tranny Pump
Suncoast Torque Converter
2nd Generation Fuel Head
Sears P1 Battery
Hot Diesel Solutions Thermostat

This is the correct part number:

55037539AA

And 410.00 is the cheapest Ive found.

_________________
2006 KJ CRD Ltd - Suncoast, GDE Eco, EGR Delete, After market T-Stat, Skid Row skids, V6 airbox, 2.5" Turbo back
2005 KJ CRD Sport-Suncoast, Transco, GDE Hot-GDE Trans, EGR Delete, Skid Row skids, V6 airbox, 2.5" Turbo back, After market S-Stat
1987 Suzuki LWB Samurai -diesel powered, custom 4 link coil suspension 38.5 SX Swampers

You said:



I found this part number:

56044738AA

and found the part here:

http://www.moparpartsoverstock.com/p/DO ... 738AA.html

For$52.87

Did you mean the viscous heater?

_________________
2005 Liberty CRD Limited
DIY Garage Remanufactured Engine with GDE Full Torque Eco Tune from mile zero.
ARP Studs
Cummins Lift Pump
Transgo HD2 Reprogramming Kit
DIY Rebuilt Tranny Pump
Suncoast Torque Converter
2nd Generation Fuel Head
Sears P1 Battery
Hot Diesel Solutions Thermostat

I got mine from Keith for a lot less than that....

DOC

_________________
2005 KJ CRD Ltd Detroit TrueTrac Bilsteins G2 GDE "HOT" ECU GDE TCM "Tow Tune" "euro" TC SEGR Weeks Elbow New HG at 130K ARPs Clean CAT aFe Filter Magnaflow Exhaust EHM Cumminos In-Tank Lift Pump Hayden Fan Clutch Nylon Fan VH Enabled with GDE lower shutoff point Recalibrated Temp Gauge Tekonsha Prodigy Sears P-1 ZDDP

55037539AA is the viscous heater, top front passenger side of the engine, connected by hoses to the tstat and cabin heater core.

56044738AA is the block heater, low down on drivers side of the engine, with a 3 prong electric wire so it can be plugged into house power. This is a common DCJ block heater that likely can be sourced from like NAPA. I suspect but don't know for sure that the actual heater element is the same as one in a household water heater in which case check it for continuity, if present element is ok so check wire, if not present element is dead. I also suspect the element comes without the wire which can be had from NAPA (KAT 28400) for like $20 and probably should be replaced at the same time.

_________________
Sold to LOST member my 05 Ltd, GDE Stg II turbo + TCM tune, SunCoast TC w. Transgo kit, Steiger window regulators, Samcos, Fumoto valve, 2nd gen filter head with Lub. Spec. bleeder, Hayden clutch & 11 blade fan, inverted spare, P-1 battery, BF Goodrich Long Trail TAs, Etecno1 glow plugs, timing belt at 50K miles/8 yrs

Thanks guys. I appreciate it.

_________________
2006 KJ CRD Ltd - Suncoast, GDE Eco, EGR Delete, After market T-Stat, Skid Row skids, V6 airbox, 2.5" Turbo back
2005 KJ CRD Sport-Suncoast, Transco, GDE Hot-GDE Trans, EGR Delete, Skid Row skids, V6 airbox, 2.5" Turbo back, After market S-Stat
1987 Suzuki LWB Samurai -diesel powered, custom 4 link coil suspension 38.5 SX Swampers

I think Green Diesel Engineering has them.

_________________
05 Liberty CRD Sport with Leather 115k
GDE ECO, No EGR, no FCV, (system gone)
Oil Drain plug P/N 090-039
K&N Air Filter, 2nd gen Fuel filter head
NEW Rockers & lifters
Mobil 1 0w-40
Stant 13519 195 deg inline Thermostat.
0 281 002 845 MAP
Etecno GX3123 7v Glow Plugs
Advance Gold 800CCA Battery
Traded it for a Quality VW TDI