has anyone made a boost leak tester for the CRD? i think i poped a hose tonight becuase i get a wooshing sound and almost no power. but there are no codes.

_________________
daily driver:06 midnight blue jeep liberty CRD sport.
mods: CRD frakenlift, 245/75R16 grabbers on Soft 8's,All J interior rack,front hitch,custom intake,ORM, EHM GDE hot tune
141k miles

Wanna borrow my Scangauge to monitor your boost?

_________________
2005 CRD "Ol' Blue"
Red Ryder carbine-action, two hundred shot range model air rifle with a compass in the stock and this thing which tells time.
My build page- RL Komodo Rear and TJM Front Bumper, armored, lifted, JBA Steel D30, 4.10s and ARB air lockers.

you can make em out of PVC plumbing parts real easy, take a look at plumbing fittings and see what looks best to you and how you want to use it

_________________
http://www.Colorado4Wheel.com
"Its not about what you can DO with your Jeep, its about where you can GO with your Jeep."
Knowledgeable - But Caustic

a little OT... what all can you monitor with a scan gauge? EGT? Boost? Trans temp?

_________________
Trevor

'05 Limited CRD Inferno Red Pearl Coat
Home made provent installed @ 35443, SEGR installed @ 35466, Fumoto valve @ 37500, trans and transfer case skid, In tank pump installed @ 43500, Suncoast TC & Transgo Shift Kit @ 44730, EGT, Boost, Trans temp gauges, Samco hoses, Rebuilt Trans w/ HD454RFE kit @ 56K, Inmotion Stage 2 @ 56K

I typically monitor MAP(boost) IAT(intake Air Temp) fWT (water Temp) and VLT(voltage).

Can't monitor TCM parameters, only ECM. I might be wrong, but I don't think we have an EGT sensor, at least its not one of the parameters supported by the ECM.

I have been working with the Scangauge support guy to see if we can monitor fuel rail pressure, but no success yet.

_________________
2005 CRD "Ol' Blue"
Red Ryder carbine-action, two hundred shot range model air rifle with a compass in the stock and this thing which tells time.
My build page- RL Komodo Rear and TJM Front Bumper, armored, lifted, JBA Steel D30, 4.10s and ARB air lockers.

ya i forgot about that on the scan gauge. i changed it over to map ya im getting 5 lbs of boost. now to figure out which pipe. and does anyone have the part #'s for them. I think i determined its the drivers side pipe.

_________________
daily driver:06 midnight blue jeep liberty CRD sport.
mods: CRD frakenlift, 245/75R16 grabbers on Soft 8's,All J interior rack,front hitch,custom intake,ORM, EHM GDE hot tune
141k miles

Ya, they are in the suggest boost hoses to samco thread.

_________________
http://www.Colorado4Wheel.com
"Its not about what you can DO with your Jeep, its about where you can GO with your Jeep."
Knowledgeable - But Caustic

found it. are the orange hoses the orginal CAC hoses? the thing that sucks is it burst right around one of the bends. anyone got a temporary solution so i can have boost the new pipe is on order.

_________________
daily driver:06 midnight blue jeep liberty CRD sport.
mods: CRD frakenlift, 245/75R16 grabbers on Soft 8's,All J interior rack,front hitch,custom intake,ORM, EHM GDE hot tune
141k miles

You should also have your intercooler checked for leaks once in a while (yearly?).

If you go to one of the better diesel shops, they can test the intercooler. Won't cost that much.

They should put 35psi to the intercooler and there should not be a loss of more than 5psi in 15 seconds. If 5 or more psi loss, you should consider a new intercooler. Most check the hoses and that is good, but very few check the intercooler. There are some that come from the factory already leaking too much.

_________________
*************************************
Environmentalist Green + Socialist Red = Facist Brown

2006 Liberty CRD, Frankenlift II, Al's A Arms, Moog LBJ's, GDE tune, Etechno GX3123 Glow plugs, Fumoto drain valve, Elephant hose CCV mod.

Duct Tape.

_________________
Manure green 2005 CRD sport4x4, GDE Hot tune, Cat Gut, OE skids, Draw tight hitch, Duramax lift pump, 160K on multiple varieties of fuel, XM radio, Escort live with Redline, fog light mod, GPS, Icom IC7000 all band radio call sign KC9QPF, Grabber AT2s on Soft 8s, FIA grill blanket.

did that it held for the day before i got the part in its all fixed now. woo hoo

_________________
daily driver:06 midnight blue jeep liberty CRD sport.
mods: CRD frakenlift, 245/75R16 grabbers on Soft 8's,All J interior rack,front hitch,custom intake,ORM, EHM GDE hot tune
141k miles

The handy mans secret weapon.