While under the Jeep recently I noticed that the insulation padding between the body and the transmission and transfer case is all torn up and falling down.

I can't find a part number for this in my parts catalog or anywhere else. Anyone know what it is?

Anyone replaced this before? Thanks!

_________________
Jeremy - Aurora, CO
L.O.S.T. #0

Future:
2016 Hydro Blue JK Unlimited Rubicon Hard Rock

Previous:
2012 Flame Red JK Unlimited Rubicon - Sold!
2012 Flame Red JK Unlimited Rubicon - Dealer buyback
2003 Silver KJ Freedom 4x4 - Sold!
32s, Frankenlift, BBars, onboard air, dirt.
KJ EVIC Install

It must be sound and heat insulation. If the dealership doesn't have it and you want to replace it, I'd try aluminized hi temp honeycomb flexible sheet insulation installed with high strength contact cement then seamed with aluminum tape. Such an animal probably can be had in a speed shop. It sounds like a PITA job!

_________________
2006 Liberty Renegade
OME, Rancho, RRO A arms, RRO roof rails w/ diy cross bars, Dual XHD7714 with Pyle speakers, drop in K&N air filter with home made CAI, 8k smittybilt winch , Sears Platinum P1, in cab winch control, 100w Optilux lights, 7" e-code Hella headlights,245/75-16C Duratracs. DIY rockrails, DIY rear double deck cargo rack.

I'm missing a decent amount of mine. Most of it got ripped off my my front DS. Then I ripped most of the hanging stuff off. I'm not to worried about it. ha

_________________
'02 Jeep KJ 4x4- Gone
'92 YJ- lift, swampers, bumpers....yeah, its pretty sweet.
*DISCLAIMER*: I can not be held liable for anything I say on the forums or in real life.
I also can not be held liable for any jeep breakage or life problems caused due to my advice being taken.

Yeah, I assume it's for sound and heat, and I definitely want to replace it as the transmission tunnel gets pretty dang hot without it there. I'm sure the dealer has it, but I was hoping to find a part number so I can figure out what I should be paying for it.

Good idea on the aluminum honeycomb. It's probably cheaper than the original insulation from the dealer, likely will work better, and it won't get torn up by squirrels and water crossings.

Oh, and yeah, it really does look like a PITA job to do.

_________________
Jeremy - Aurora, CO
L.O.S.T. #0

Future:
2016 Hydro Blue JK Unlimited Rubicon Hard Rock

Previous:
2012 Flame Red JK Unlimited Rubicon - Sold!
2012 Flame Red JK Unlimited Rubicon - Dealer buyback
2003 Silver KJ Freedom 4x4 - Sold!
32s, Frankenlift, BBars, onboard air, dirt.
KJ EVIC Install

Just dynamat the inside.

_________________
'02 Jeep KJ 4x4- Gone
'92 YJ- lift, swampers, bumpers....yeah, its pretty sweet.
*DISCLAIMER*: I can not be held liable for anything I say on the forums or in real life.
I also can not be held liable for any jeep breakage or life problems caused due to my advice being taken.

Freedomkj, I looked through my library and I couldn't even find a parts page with the stuff listed on it.

_________________
2006 Liberty Renegade
OME, Rancho, RRO A arms, RRO roof rails w/ diy cross bars, Dual XHD7714 with Pyle speakers, drop in K&N air filter with home made CAI, 8k smittybilt winch , Sears Platinum P1, in cab winch control, 100w Optilux lights, 7" e-code Hella headlights,245/75-16C Duratracs. DIY rockrails, DIY rear double deck cargo rack.