When I had my Suncoast installed they put 3 full gallons of Amsoil ATF in. It has been leaking out of both ends of the tranny ever since. I check it cold in the morning since I can't ever get it up to the 180 degree "hot" temp. It's over the mark quite a bit. So I removed about 40 oz so far. Does anyone know what a complete fill is on this unit with a stock pan?

_________________
2006 Jeep Liberty Limited CRD (purchased 10/30/12 w/ 52k miles) GDE HotTune & Eco TCU, Suncoast TC, Amsoil Full SAPS (EFM) 5w40, Amsoil ATF, 7" touchscreen Android powered stereo (direct from China) w/ 4G LTE mobile data for streaming Netflix, HBO GO, Slingbox, Pandora, etc.

It is 13.4 lts or 14 quarts

Total fill is 14.1 quarts.

_________________
2011 Ram 2500 6.7L Cummins Deleted w/MiniMaxx G56 HDD 5W-30 & Bypass Oil Filter
2005 Liberty CRD Limited (Cracked Block) Sold
2015 Cherokee Latitude 3.2L V6 (Replaced CRD)
1992 Dodge Stealth RT Twin Turbo Pearl White/Black Leather
2008 Kubota GR2110 Diesel
2006 Key West 186 Sportsman w/135HP Honda OB
1943 Farmall H Restored

Really? I know that's what the Amsoil site said but it just seems to be high on the dipstick and leaking out everywhere... I wonder if there was some fluid that didn't get drained out of the trans or cooler lines? That would seem almost impossible...

_________________
2006 Jeep Liberty Limited CRD (purchased 10/30/12 w/ 52k miles) GDE HotTune & Eco TCU, Suncoast TC, Amsoil Full SAPS (EFM) 5w40, Amsoil ATF, 7" touchscreen Android powered stereo (direct from China) w/ 4G LTE mobile data for streaming Netflix, HBO GO, Slingbox, Pandora, etc.

Is the transfer case included in the sump?

_________________
2006 Jeep Liberty Limited CRD (purchased 10/30/12 w/ 52k miles) GDE HotTune & Eco TCU, Suncoast TC, Amsoil Full SAPS (EFM) 5w40, Amsoil ATF, 7" touchscreen Android powered stereo (direct from China) w/ 4G LTE mobile data for streaming Netflix, HBO GO, Slingbox, Pandora, etc.

Nope.

_________________
05CRD: GDE Hot ECU & TCM tunes, Provent, Cat filter, Facet lift pump, TransGo kit, Florida TC, Samcos, stainless brake lines, HDS thermostat, Renegade light bar,
Bilstein adjustables, Al's Gen 4.5 Arms, 235/85-16 Duratracs, DTT rear, Elocker front, EVIC+TPMS, Turbo timer, McNally pillar gauges, Weeks Stage II kit.

In the sump there is only 5-6 quarts then rest is hiding near TC about 9 quarts the trick to replacing all fluid is to open one side of trans cooler and stop when you get to about 9 Q then top with new fluid and drain sump for rest of it and top up. In your case you need to siphon a lot of fluid back. Even mine is overfilled and I need it to take back for siphon fix.

I wonder if the Suncoast doesn't hold as much fluid as the stock TC?

_________________
2006 Jeep Liberty Limited CRD (purchased 10/30/12 w/ 52k miles) GDE HotTune & Eco TCU, Suncoast TC, Amsoil Full SAPS (EFM) 5w40, Amsoil ATF, 7" touchscreen Android powered stereo (direct from China) w/ 4G LTE mobile data for streaming Netflix, HBO GO, Slingbox, Pandora, etc.